Experimental investigation on combustion of hydrogen–oxygen and methane–oxygen mixtures in the medium of low-superheated steam

被引：9

作者：

Pribaturin N.A. ^{[1
]}

Fedorov V.A. ^{[2
]}

Alekseev M.V. ^{[1
]}

Bogomolov A.R. ^{[1
]}

Sorokin A.L. ^{[1
]}

Azikhanov S.S. ^{[3
]}

Shevyrev S.A. ^{[3
]}

机构：

[1] Kutateladze Institute of Thermal Physics, Siberian Branch, Russian Academy of Sciences, pr. Akademika Lavrent’eva 1, Novosibirsk

[2] ZAO Turbokon Scientific and Production Implementation Company, ul. Komsomol’skaya Roshcha 43, Kaluga

[3] Gorbachev Kuzbass State Technical University, ul. Vesennyaya 28, Kemerovo

来源：

Thermal Engineering | 2016年 / 63卷 / 05期

关键词：

combustion; hydrogen–oxygen mixture; methane; oxygen; steam; steam turbine; thermal power plant;

D O I：

10.1134/S0040601516050086

中图分类号：

学科分类号：

摘要：

Experimental data are represented on the investigation of combustion of hydrogen–oxygen and methane–oxygen mixtures in the medium of low-superheated (initial temperature of approximately 150°C) steam at atmospheric pressure. The influence of the ratio of mass flows of the combustible mixture and steam on the qualitative composition of combustion products and the temperature of produced steam is revealed. Main laws for combustion of the hydrogen–oxygen mixture within the steam flow, which affect the completeness of mixture combustion, are determined. Experimental data on the influence of concentrations of the hydrogen–oxygen mixture within the flow of the steam and the combustible mixture upon the completeness of combustion are given. It is found that, when burning the hydrogen–oxygen mixture within the steam flow with a temperature of 1000–1200°C, it is possible using a variation of the combustible mixture flow. At the same time, the volume fraction of noncondensable gases in the produced steam is no more than 2%. It is revealed that there are several combustion modes of the hydrogen–oxygen mixture within the steam flow, in which, in one case, the steam always suppresses combustion and, in another one, detonation of the combustible mixture combustible mixture occurs. It is found that with the excess air factor close to unit, the combustion of the methane–oxygen mixture within steam and the vapor conversion of methane, which result in the appearance of free hydrogen in the produced high-temperature steam, are possible. The description and the principle of the operation of the experimental bench for investigation of combustion of methane–oxygen and hydrogen–oxygen mixtures in the medium of steam are given. Results of experimental investigations of burning fuel and oxygen in the medium of steam are used in the development of a steam superheater for a hightemperature steam turbine. © 2016, Pleiades Publishing, Inc.

引用

页码：336 / 341

页数：5

共 8 条

[1]

Fedorov A.V., Mil'man O.O., Shifrin B.A., High-Effective Technologies of Electroenergy Production with the Use of Organic and Hydrogen Fuel, (2007)

[2]

Favorskii O.N., Leont'ev A.I., Fedorov V.A., Mil'man O.O., Calculation–experimental foundation of construction of coal–hydrogen power station with high-temperature (850–1500°C) with steam turbines, Proc. 5th Ross. Nat. Conf. on Heatexchange, 1, pp. 63-68, (2010)

[3]

Mil'man O.O., Pribaturin N.A., Fedorov V.A., Thermophysical problems of construction of combined electrogenerating plants with tufbine energoblocks, Proc 4th Ross. Nat. Conf. on Heatexchange, 1, pp. 258-262, (2006)

[4]

Malyshenko S.P., Nazarova O.V., Sarumov Y.A., Thermodynamic aspects of hydrogen use for solution of some problems of power engineering, Teploenergetika, 10, pp. 43-47, (1986)

[5]

Bebelin I.N., Volkov A.G., Gryaznov A.N., Malyshenko S.P., Development and investigation of an experimental hydrogen–oxygen steam generator of 10-Mw thermal capacity, Therm. Eng., 44, pp. 657-662, (1997)

[6]

Volchkov E.P., Dvornikov N.A., Perepechko L.N., Mathematical simulation of turbulent burning of hydrogen in boundaty layer, Inzh.-Fiz. Zh., 71, pp. 86-91, (1998)

[7]

Schwiedernoch R., Tischer S., Correa C., Deutschmann O., Experimental and numerical study on the transient behavior of partial oxidation of methane in a catalytic monolith, Chem. Eng. Sci., 58, pp. 633-642, (2003)

[8]

Cormier J.M., Rusu I., Syngas production via methane steam reforming with oxygen: Plasma reactors versus chemical reactors, J. Phys. D: Appl. Phys., 34, pp. 2798-2803, (2001)

← 1 →