Pressure-driven flows of concentrated alumina suspensions depending on dispersion states of particles

被引：0
作者：
Woojoo Han
Kyung Hyun Ahn
机构：
[1] Seoul National University,School of Chemical and Biological Engineering, Institute of Chemical Process
来源：
Rheologica Acta | 2014年 / 53卷
关键词：
Concentrated suspension; Complex flow; Shear banding; Solid-liquid transition; Pressure fluctuation;
D O I：
暂无
中图分类号：
学科分类号：
摘要：
The flow developments of 25 vol% alumina suspensions in slit channel were visualized and analyzed depending on the dispersion states. For the coagulated alumina suspension, the shear stress showed an N curve that included a region of stress decrease with an increase in shear rate followed by a monotonic increase. Depending on the region in the stress curve, the flow profile changed from a shear-banded profile to a plug-like flow profile similar to the Newtonian fluid. In addition, it was observed that the transient flow behavior over time at high shear rate in liquid state experienced all of the steady state flow profiles at lower shear rates in solid-liquid transition. During the solid-liquid transition, the flow profile was found to be shear banded, and the pressure profile did not reach a steady state but fluctuated with a characteristic time period. In contrast, the well-dispersed suspension showed only a monotonic increase of shear stress in the range of shear rates we could measure, indicating that the suspension was in liquid state. The flow profile was plug-like, and the pressure was fluctuating without any characteristic time period.
引用
收藏
页码：209 / 218
页数：9
相关论文
共 152 条
[1]  
Azzouzi H(2005)Temporal oscillations of the shear stress and scattered light in a shear banding-shear thickening micellar solution Eur Phys J E 17 507-514
[2]  
Decruppe JP(1989)Shear-thickening (“Dilatancy”) in suspensions of nonaggregating solid particles dispersed in Newtonian liquids J Rheol 33 329-336
[3]  
Lerouge S(1994)Shear-induced isotropic-to-nematic phase transition in equilibrium polymers Europhys Lett 25 521-526
[4]  
Greffier O(2009)Quantitative imaging of colloidal flows Adv Colloid Interf Sci 146 1-17
[5]  
Barnes HA(2010)Shear banding and flow-concentration coupling in colloidal glasses Phys Rev Lett 105 268301-255
[6]  
Berret JF(1998)Stability of aqueous J Am Ceram Soc 71 250-1708
[7]  
Roux DC(1997)-Al AIChE J 43 1700-78
[8]  
Porte G(2000)O AlChE J 46 72-1878
[9]  
Lindner P(1997) suspensions with poly(methacrylic acid) polyelectrolyte Phys Rev E 56 1869-046004
[10]  
Besseling R(2004)Shear and compressive rheology of aggregated alumina suspensions Phys Rev Lett 93 046001-215504
12345678910