Novel, stable and durable superhydrophobic film on glass prepared by RF magnetron sputtering

被引：18
|
作者：
Yuan, Yuan [1 ]
Duan, Yizheng [1 ]
Zuo, Zhiping [2 ]
Yang, Lijun [2 ]
Liao, Ruijin [2 ]
机构：
[1] Chongqing Univ, Coll Mat Sci & Engn, Chongqing 400044, Peoples R China
[2] Chongqing Univ, State Key Lab Power Transmiss Equipment & Syst Se, Chongqing, Peoples R China
来源：
MATERIALS LETTERS | 2017年 / 199卷
关键词：
Nanostructured; Superhydrophobic; Magnetron sputtering; Annealing; Durability; ANTIICING BEHAVIOR; COATINGS; SURFACES;
D O I：
10.1016/j.matlet.2017.04.067
中图分类号：
T [工业技术];
学科分类号：
08 ;
摘要：
A novel and facile approach has been adopted to fabricate a nanostructured superhydrophobic (SHP) film on glass by radio frequency (RF) magnetron sputtering. The surface morphology, XRD pattern, chemical composition and wettability were analyzed by corresponding methods. It was found that the as-prepared SHP surface exhibited a prominent superhydrophobicity with a contact angle (CA) up to 168.9 degrees and sliding angle less than 1 degrees, which was mainly attributed to the low surface energy of hexadecyltrimethoxy silane and Al2O3-ZnO (mass ratio (Al/Zn) approximate to 1:1.2) nanofibers along with the presence of high proportions of micro/nano air pockets induced by a hierarchical composite network. Moreover, the as-prepared SHP surface demonstrated good stability under outdoor and ambient environment, and retained its superhydrophobicity even at severe temperatures as well as in strong corrosive surroundings. (C) 2017 Elsevier B.V. All rights reserved.
引用
收藏
页码：97 / 100
页数：4
相关论文
共 50 条
  • [41] Investigation of silicon carbon oxynitride thin film deposited by RF magnetron sputtering
    Aghaei, Abbas Ali
    Eshaghi, Akbar
    Ramazani, Mazaher
    Zabolian, Hossein
    Abbasi-Firouzjah, Marzieh
    APPLIED SURFACE SCIENCE ADVANCES, 2024, 19
  • [42] Ultraviolet photodetectors based on MgZnO thin film grown by RF magnetron sputtering
    Shiau, Jr-Shiang
    Brahma, Sanjaya
    Liu, Chuan-Pu
    Huang, Jow-Lay
    THIN SOLID FILMS, 2016, 620 : 170 - 174
  • [43] Effect of annealing on conductivity behavior of undoped zinc oxide prepared by rf magnetron sputtering
    Xing, G. Z.
    Yao, B.
    Cong, C. X.
    Yang, T.
    Xie, Y. P.
    Li, B. H.
    Shen, D. Z.
    JOURNAL OF ALLOYS AND COMPOUNDS, 2008, 457 (1-2) : 36 - 41
  • [44] Optical and electrical properties of vanadium pentoxide films prepared by RF reactive magnetron sputtering
    Zhang, Sheng-Bin
    Zuo, Dun-Wen
    Lu, Wen-Zhuang
    Zuo, Yang-Ping
    Guangxue Jingmi Gongcheng/Optics and Precision Engineering, 2015, 23 (09): : 2438 - 2445
  • [45] Structure and properties of Si-implanted VN coatings prepared by RF magnetron sputtering
    Zhao, Hongjian
    Yu, Lihua
    Mu, Chunyan
    Ye, Fuxing
    MATERIALS CHARACTERIZATION, 2016, 117 : 65 - 75
  • [46] Effects of parameters on the performance of amorphous IGZO thin films prepared by RF magnetron sputtering
    Niu J.-W.
    Ma R.-X.
    Wang Y.-Y.
    Li S.-N.
    Cheng S.-Y.
    Liu Z.-L.
    Ma, R.-X. (maruixin@ustb.edu.cn), 1600, Springer Verlag (10): : 347 - 351
  • [47] Structural and optical properties of yttrium trioxide thin films prepared by RF magnetron sputtering
    Yan, F.
    Liu, Z. T.
    Liu, W. T.
    VACUUM, 2011, 86 (01) : 72 - 77
  • [48] Properties of erbium-doped gallium nitride films prepared by RF magnetron sputtering
    Prajzler, V
    Hüttel, I
    Perina, V
    Machovic, V
    Schröfel, J
    Spirková, J
    Oswald, J
    Studnicka, V
    Novotná, M
    MICROWAVE AND OPTICAL TECHNOLOGY 2003, 2003, 5445 : 294 - 297
  • [49] Biomineralization capability of adherent bio-glass films prepared by magnetron sputtering
    Stan, G. E.
    Pina, S.
    Tulyaganov, D. U.
    Ferreira, J. M. F.
    Pasuk, I.
    Morosanu, C. O.
    JOURNAL OF MATERIALS SCIENCE-MATERIALS IN MEDICINE, 2010, 21 (04) : 1047 - 1055
  • [50] Self-texture control of ZnO films prepared by reactive RF magnetron sputtering
    Novak, Petr
    Sutta, Pavol
    Netrvalova, M.
    Riha, Jan
    Medlin, Rostislav
    MATERIALS AND APPLICATIONS FOR SENSORS AND TRANSDUCERS III, 2014, 605 : 219 - 222
12345