Assessment on R-410A saturated flow boiling heat transfer subject to periodic oscillating heat flux inside an annular duct

被引:4
|
作者
Li, Wen-Ken [1 ]
Hsu, Shu-Hao [2 ]
Lin, Tsing-Fa [2 ]
Chen, Chien-An [2 ,3 ]
Yan, Wei-Mon [4 ,5 ]
机构
[1] Chung Yuan Christian Univ, Dept Mech Engn, Taoyuan 32023, Taiwan
[2] Natl Yang Ming Chiao Tung Univ, Dept Mech Engn, Hsinchu 30010, Taiwan
[3] E One MOLI Energy Corp, Dept Res & Dev, Tainan 74144, Taiwan
[4] Natl Taipei Univ Technol, Res Ctr Energy Conservat New Generat Residential, Commercial & Ind Sect, Taipei 10608, Taiwan
[5] Natl Taipei Univ Technol, Dept Energy & Refrigerating Air Conditioning Engn, Taipei 10608, Taiwan
关键词
Saturated flow boiling; Oscillating heat flux; Mass flux; Flow patterns; Intermittent boiling flow; BUBBLE CHARACTERISTICS; CONVECTION; FLUIDS; MICROCHANNEL; EQUATIONS; MAP;
D O I
10.1016/j.ijthermalsci.2022.107625
中图分类号
O414.1 [热力学];
学科分类号
摘要
The objective of this study is concerned with assessing experimentally the heat transfer of time-dependent saturated flow boiling (TDSFB) for refrigerant R-410 A stemming from oscillations in the heat flux inside an annular duct with the gap of delta = 2 mm in order to improve the energy efficiency of heat exchanger system. The influences of operating parameters, such as mean applied heat flux q, heat flux oscillation amplitude Delta q/q, mass flux of refrigerant G, oscillation period tp, and saturation temperature Tsat, on heat transfer characteristics of TDSFB are systematically explored. From the present experimental results, it is found that increasing mean applied heat flux enhances the average wall superheat and boiling heat transfer coefficient (BHTC, hr); while an increase in either Delta q/q or tp exerts very minor influence on the boiling curve and hr. As the q oscillates in the triangular waveform, the wall temperature (Tw) varies in sinusoidal waves at the same frequency of q. At low, intermediate, and high q, three different flow patterns versus time are observed and named single-phase flow (SPF), intermittent boiling flow (IBF), and persistent boiling flow (PBF). The oscillation amplitudes of Tw and hr are increased with the increases of Delta q/q. Enhancing either G or Tsat tends to result in a slight decrease in Tw, but an increase in hr. Moreover, the Tw does not fluctuate with the oscillation of lower q under a shorter tp due to the tube thermal inertia, but oscillates significantly as the tp is raised. Finally, a correlation equation is presented to identify the bounds, distinguishing the three different flow patterns of R-410 A TDSFB subject to oscillatory heat flux inside horizontal annuli.
引用
收藏
页数:13
相关论文
共 50 条
  • [41] Experimental study on R-410a evaporation heat transfer characteristics in oblong shell and plate heat exchanger
    Kim, In-Kwan
    Park, Jae-Hong
    Kwon, Yong-Ha
    Kim, Young-Soo
    HEAT TRANSFER ENGINEERING, 2007, 28 (07) : 633 - 639
  • [42] Heat transfer characteristics of R410A-oil mixture flow boiling inside a 7 mm straight microfin tube
    Hu, Haitao
    Ding, Guoliang
    Wang, Kaijian
    INTERNATIONAL JOURNAL OF REFRIGERATION-REVUE INTERNATIONALE DU FROID, 2008, 31 (06): : 1081 - 1093
  • [43] Heat transfer characteristics of R410A-oil mixture flow boiling inside a 7 mm straight smooth tube
    Hu, Haitao
    Ding, Guoliang
    Wei, Wenjian
    Wang, Zhence
    Wang, Kaijian
    EXPERIMENTAL THERMAL AND FLUID SCIENCE, 2008, 32 (03) : 857 - 869
  • [44] Heat transfer correlation for saturated flow boiling of water
    Fang, Xiande
    Zhou, Zhanru
    Wang, Hao
    APPLIED THERMAL ENGINEERING, 2015, 76 : 147 - 156
  • [45] Slip flow heat transfer in annular microchannels with constant heat flux
    Duan, Zhipeng
    Muzychka, Y. S.
    JOURNAL OF HEAT TRANSFER-TRANSACTIONS OF THE ASME, 2008, 130 (09):
  • [46] A study of the flow boiling heat transfer in an annular heat exchanger with a mini gap
    Musial, Tomasz
    Piasecka, Magdalena
    Hozejowska, Sylwia
    EXPERIMENTAL FLUID MECHANICS 2016 (EFM16 ), 2017, 143
  • [47] CONDENSATION HEAT TRANSFER AND PRESSURE DROP OF R-410A IN FLAT ALUMINUM MULTIPORT TUBES
    Kim, Nae-Hyun
    Go, Min-Geon
    5TH IIR INTERNATIONAL CONFERENCE ON THERMOPHYSICAL PROPERTIES AND TRANSFER PROCESSES OF REFRIGERANTS (TPTPR), 2017, : 912 - 916
  • [48] Heat transfer characteristics of flow boiling in micro-fin tubes with R410A
    Ma, Hugen
    Jiang, Gang
    Bai, Jianmei
    Huagong Xuebao/CIESC Journal, 2011, 62 (01): : 41 - 46
  • [49] CONDENSATION HEAT TRANSFER AND PRESSURE DROP OF R-410A IN FLAT ALUMINUM MULTIPORT TUBES
    Kim, Nae-Hyun
    Go, Min-Geon
    5TH IIR INTERNATIONAL CONFERENCE ON THERMOPHYSICAL PROPERTIES AND TRANSFER PROCESSES OF REFRIGERANTS (TPTPR), 2017, : 257 - 261
  • [50] Novel Saturated Flow Boiling Heat Transfer Correlation for R32 Refrigerant
    Turgut, Oguz Emrah
    Asker, Mustafa
    Genceli, Hadi
    Coban, Mustafa Turhan
    JOURNAL OF THERMOPHYSICS AND HEAT TRANSFER, 2022, 36 (01) : 215 - 220