Nafion/Analcime and Nafion/Faujasite composite membranes for polymer electrolyte membrane fuel cells

被引：38

作者：

Kongkachuichay, Paisan ^{[1
]}

Pimprom, Siraprapa ^{[1
]}

机构：

[1] Kasetsart Univ, Fac Engn, Dept Chem Engn, Bangkok 10900, Thailand

来源：

CHEMICAL ENGINEERING RESEARCH & DESIGN | 2010年 / 88卷 / 4A期

关键词：

Composite membrane; Fuel cell; Nafion; Zeolites; HIGH-TEMPERATURE-OPERATION; ACID; 100-DEGREES-C; NAFION(R); PEMFCS;

D O I：

10.1016/j.cherd.2009.08.017

中图分类号：

TQ [化学工业];

学科分类号：

0817 ;

摘要：

The Nafion/zeolite composite membranes were synthesized for polymer electrolyte fuel cells (PEMFCs) by adding zeolite in the matrix of Nafion polymer. Two kinds of zeolites, Analcime and Faujasite, having different Si/Al ratio were used. The physico-chemical properties of the composite membranes such as water uptake, ion-exchange capacity, hydrogen permeability, and proton conductivity were determined. The fabricated composite membranes showed the significant improvement of all tested properties compared to that of pure Nafion membrane. The maximum proton conductivity of 0.4373 S cm(-1) was obtained from Nafion/Analcime (15%) at 80 degrees C which was 6.8 times of pure Nafion (0.0642 S cm(-1) at 80 degrees C). Conclusively, Analcime exhibited higher improvement than Faujasite. (C) 2009 The Institution of Chemical Engineers. Published by Elsevier B.V. All rights reserved.

引用

页码：496 / 500

页数：5

共 18 条

[1] Investigation of PEMFC operation above 100°C employing perfluorosulfonic acid silicon oxide composite membranes [J].

Adjemian, KT ;

Srinivasan, S ;

Benziger, J ;

Bocarsly, AB .

JOURNAL OF POWER SOURCES, 2002, 109 (02) :356-364

[2] Polymeric proton conducting membranes for medium temperature fuel cells (110-160°C) [J].

Alberti, G ;

Casciola, M ;

Massinelli, L ;

Bauer, B .

JOURNAL OF MEMBRANE SCIENCE, 2001, 185 (01) :73-81

[3] High temperature operation of a composite membrane-based solid polymer electrolyte water electrolyser [J].

Antonucci, V. ;

Di Blasi, A. ;

Baglio, V. ;

Ornelas, R. ;

Matteucci, F. ;

Ledesma-Garcia, J. ;

Arriaga, L. G. ;

Arico, A. S. .

ELECTROCHIMICA ACTA, 2008, 53 (24) :7350-7356

[4]

BRECK DW, 1974, ZEOLITE MOL SIEVES, P379

[5] Nafion® 115/zirconium phosphate composite membranes for operation of PEMFCs above 100 °C [J].

Costamagna, P ;

Yang, C ;

Bocarsly, AB ;

Srinivasan, S .

ELECTROCHIMICA ACTA, 2002, 47 (07) :1023-1033

[6]

DYER A, 1988, INTRO ZEOLITE MOL SI, P12

[7] Changes in Cu2+ environment upon wet deactivation of Cu-ZSM-5 deNOx catalysts [J].

Gómez, SA ;

Campero, A ;

Martínez-Hernández, A ;

Fuentes, GA .

APPLIED CATALYSIS A-GENERAL, 2000, 197 (01) :157-164

[8]

*GSA RES, 2000, CAT EXCH

[9] An investigation of the effect of high pressure on the structure of siliceous zeolite Y [J].

Havenga, EA ;

Huang, YN ;

Secco, RA .

MATERIALS RESEARCH BULLETIN, 2003, 38 (03) :381-387

[10] Solid acid membranes for high temperature (> 140 °C) proton exchange membrane fuel cells [J].

Hogarth, WHJ ;

da Costa, JCD ;

Lu, GQ .

JOURNAL OF POWER SOURCES, 2005, 142 (1-2) :223-237

← 1 2 →