Deposition of graphene-copper composite film by cold spray from particles with graphene grown on copper particles

被引:20
|
作者
Choi, Jongbeom [1 ]
Okimura, Nana [1 ]
Yamada, Takatoshi [2 ]
Hirata, Yuki [1 ]
Ohtake, Naoto [1 ]
Akasaka, Hiroki [1 ]
机构
[1] Tokyo Inst Technol, Tokyo, Japan
[2] Natl Inst Adv Ind Sci & Technol, Tsukuba, Japan
关键词
Graphene; Tribological property; Structural damage; Uniform distribution; Cold spray; LAYER GRAPHENE; TRIBOLOGICAL PROPERTIES; MATRIX COMPOSITES; REINFORCED METAL; SINGLE-LAYER; LARGE-AREA; MECHANISM; STRENGTH;
D O I
10.1016/j.diamond.2021.108384
中图分类号
T [工业技术];
学科分类号
08 ;
摘要
Graphene has been used to improve tribological property due to its extraordinary properties. For graphene composite, obtaining uniformly distributed and less damaged graphene is important for better improvement. In this research, graphene was fabricated on copper particle by thermal chemical vapor deposition to minimize structural damage and obtain uniform distribution. The obtained graphene-coated copper composite particle was deposited by cold spray which is less deteriorative for graphene. The scanning electron microscope images show that graphene appeared to surface of copper particle without any agglomeration. Raman spectrum indicates that mostly monolayer graphene was obtained. Uniform distribution of graphene was observed after the deposition by cold spray. Furthermore, the deposition by cold spray induced neglectable structural damages on graphene. Nevertheless 0.019 wt% of carbon corresponding to graphene was incorporated in the composite film, graphene improved tribological properties in comparison with those of the copper film; the average friction coefficient values were 0.60 and 0.46 for the copper and composite films, respectively, and the calculated specific wear rates of the films were 8.6 x 10-4 and 5.2 x 10-4 mm3/N center dot m for the copper and graphene-copper composite films, respectively. The improved tribological properties resulted from the low shearing and passivation film by the incorporated graphene.
引用
收藏
页数:7
相关论文
共 50 条
  • [1] Evaluating the Application of Cold Spray Technology for the Deposition of Copper-Graphene Composite Coatings
    Zarei, Fatemeh
    Lordejani, Amir Ardeshiri
    Ruan, Siyuan
    Yin, Shuo
    Guagliano, Mario
    Lupoi, Rocco
    Bagherifard, Sara
    COATINGS, 2025, 15 (02):
  • [2] Enhanced electrical conductivity in graphene-copper multilayer composite
    Pan, Chaochao
    Gaur, Anand P. S.
    Lynn, Matthew
    Olson, Madison P.
    Ouyang, Gaoyuan
    Cui, Jun
    AIP ADVANCES, 2022, 12 (01)
  • [3] Manufacturing Graphene-Encapsulated Copper Particles by Chemical Vapor Deposition in a Cold Wall Reactor
    Chen, Shujing
    Zehri, Abdelhafid
    Wang, Qianlong
    Yuan, Guangjie
    Liu, Xiaohua
    Wang, Nan
    Liu, Johan
    CHEMISTRYOPEN, 2019, 8 (01) : 58 - 63
  • [4] Embedment of copper particles into polymers by cold spray
    King, Peter C.
    Poole, Andrew J.
    Horne, Susan
    de Nys, Rocky
    Gulizia, Stefan
    Jahedi, Mahnaz Z.
    SURFACE & COATINGS TECHNOLOGY, 2013, 216 : 60 - 67
  • [5] Laser additive manufacturing bulk graphene-copper nanocomposites
    Hu, Zengrong
    Chen, Feng
    Lin, Dong
    Nian, Qiong
    Parandoush, Pedram
    Zhu, Xing
    Shao, Zhuqiang
    Cheng, Gary J.
    NANOTECHNOLOGY, 2017, 28 (44)
  • [6] Graphene-copper composite with micro-layered grains and ultrahigh strength
    Wang, Lidong
    Yang, Ziyue
    Cui, Ye
    Wei, Bing
    Xu, Shichong
    Sheng, Jie
    Wang, Miao
    Zhu, Yunpeng
    Fei, Weidong
    SCIENTIFIC REPORTS, 2017, 7
  • [7] Numerical Simulation of the Cold Spray Deposition of Copper Particles on Polyether Ether Ketone (PEEK) Substrate
    Tang, Wei
    Zhang, Jiayuan
    Li, Yan
    Yu, Bo
    Zhao, Jiabin
    JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2021, 30 (07) : 1792 - 1809
  • [8] Enhancement of the mechanical properties of graphene-copper composites with graphene-nickel hybrids
    Tang, Yanxia
    Yang, Xiaomin
    Wang, Rongrong
    Li, Maoxin
    MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2014, 599 : 247 - 254
  • [9] SYNTHETIC GRAPHENE GROWN BY CHEMICAL VAPOR DEPOSITION ON COPPER FOILS
    Chung, Ting Fung
    Shen, Tian
    Cao, Helin
    Jauregui, Luis A.
    Wu, Wei
    Yu, Qingkai
    Newell, David
    Chen, Yong P.
    INTERNATIONAL JOURNAL OF MODERN PHYSICS B, 2013, 27 (10):
  • [10] Role of defects in the mechanical properties of graphene-copper heterostructures
    Felix, T. T.
    Chavez-Castillo, M. R.
    Meza-Montes, L.
    NANOTECHNOLOGY, 2022, 33 (33)