Use of Innovative Gel Electrolytes for Electrochemical Corrosion Measurements on Carbon and Galvanized Steel Surfaces

被引:12
作者
Monrrabal, Gleidys [1 ]
Bautista, Asuncion [1 ]
Velasco, Francisco [1 ]
机构
[1] Univ Carlos III Madrid, Mat Sci & Engn Dept IAAB, Ave Univ 30, Leganes 28911, Spain
关键词
carbon steel; corrosion monitoring; EIS; galvanized steel; gel electrolyte; polarization curves; portable cell; AERATED SULFATE MEDIUM; POLYMER ELECTROLYTE; CREVICE CORROSION; ZINC DISSOLUTION; PART II; BEHAVIOR; AGAR; XPS; EIS; COATINGS;
D O I
10.5006/3309
中图分类号
T [工业技术];
学科分类号
08 ;
摘要
This work analyzes the feasibility of using gel electrolytes in portable cells to easily perform electrochemical corrosion measurements on carbon steel and galvanized steel components. A gel manufactured from glycerol and agar, with chlorides and optimized conductivity, has been selected for this study. This gel is easily adaptable to nonflat surfaces and has no risk of crevice corrosion interferences during the measurements. Polarization and electrochemical impedance spectroscopy measurements have been performed with a portable cell with a gel electrolyte. The results have been compared to those obtained in a liquid electrolyte with the same saline composition. The effect of using gel electrolytes on the development of the anodic and cathodic processes when the metal surfaces corrode actively has been analyzed in depth. The changes on the composition of outer oxides due to the gel exposure have also been studied by x-ray photospectroscopy to achieve a better understanding of the results. The gel electrolyte has proved to be an adequate medium for obtaining relevant information about the corrosion performance of active carbon and galvanized steel, although it has a somewhat lower aggressiveness than the liquid electrolyte with the same saline composition.
引用
收藏
页码:1502 / 1512
页数:11
相关论文
共 50 条
[21]   Effect of environmental factors on electrochemical corrosion of galvanized steel wires for bridge cables [J].
Li, Rou ;
Miao, Changqing ;
Wei, Tinghua .
ANTI-CORROSION METHODS AND MATERIALS, 2022, 69 (01) :111-118
[22]   Gravimetric and electrochemical methods to evaluate the performance of corrosion inhibitors for galvanized steel strips [J].
Rodriguez-Perez, Mayra Y. ;
de la Garza-Garza, Maribel ;
Almeraya-Calderon, Facundo ;
Artigas, Alfredo ;
Monsalve, Alberto ;
Perez-Gonzalez, Francisco A. ;
Ramirez-Ramirez, Javier H. ;
Colas, Rafael ;
Garza-Montes-de-Oca, Nelson F. .
CORROSION REVIEWS, 2018, 36 (03) :295-304
[23]   Advances in the design of a gel-cell electrochemical sensor for corrosion measurements on metallic cultural heritage [J].
Ramirez Barat, Blanca ;
Cano, Emilio ;
Letardi, Paola .
SENSORS AND ACTUATORS B-CHEMICAL, 2018, 261 :572-580
[24]   Electrochemical impedance study on galvanized steel corrosion under cyclic wet-dry conditions-influence of time of wetness [J].
Yadav, AP ;
Nishikata, A ;
Tsuru, T .
CORROSION SCIENCE, 2004, 46 (01) :169-181
[25]   Conducting polyanilline based paints on hot dip galvanized low carbon steel for corrosion protection [J].
Deshpande, P. ;
Vagge, S. ;
Jagtap, S. ;
Khiarnar, R. ;
Kelkar, S. ;
More, M. .
BULGARIAN CHEMICAL COMMUNICATIONS, 2012, 44 (04) :318-323
[26]   Electrochemical study of the corrosion behaviour of carbon steel in fracturing fluid [J].
Gaetano Palumbo ;
J. Banaś ;
A. Bałkowiec ;
J. Mizera ;
U. Lelek-Borkowska .
Journal of Solid State Electrochemistry, 2014, 18 :2933-2945
[27]   Electrochemical study of the corrosion behaviour of carbon steel in fracturing fluid [J].
Palumbo, Gaetano ;
Banas, J. ;
Bakowiec, A. ;
Mizera, J. ;
Lelek-Borkowska, U. .
JOURNAL OF SOLID STATE ELECTROCHEMISTRY, 2014, 18 (11) :2933-2945
[28]   Electrochemical corrosion behavior of carbon steel with bulk coating holidays [J].
Song, YQ ;
Du, CW ;
Li, XG .
JOURNAL OF UNIVERSITY OF SCIENCE AND TECHNOLOGY BEIJING, 2006, 13 (01) :37-43
[29]   Design of gel electrolytes for electrochemical studies on metal surfaces with complex geometry [J].
Monrrabal, G. ;
Guzman, S. ;
Hamilton, I. E. ;
Bautista, A. ;
Velasco, F. .
ELECTROCHIMICA ACTA, 2016, 220 :20-28
[30]   Electrochemical corrosion and impedance study of SAE1045 steel under gel-like environment [J].
Gu, Kunming ;
Lv, Leyang ;
Lu, Zhaolong ;
Yang, Haipeng ;
Mao, Fei ;
Tang, Jiaoning .
CORROSION SCIENCE, 2013, 74 :408-413