Effect of the mode of heat withdrawal on the asymmetry of temperature profiles in reverse-flow reactors. Catalytic combustion of methane as a test case

被引:47
作者
Gosiewski, Krzysztof
Warmuzinski, Krzysztof
机构
[1] Jan Dlugosz Univ Czestochowa, Inst Chem & Environm Protect, PL-42201 Czestochowa, Poland
[2] Polish Acad Sci, Inst Chem Engn, PL-44100 Gliwice, Poland
关键词
asymmetry; reverse-flow reactors; combustion; dynamic simulation; heat recovery; mathematical modelling;
D O I
10.1016/j.ces.2007.02.013
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
Results of simulations are presented concerning a reverse-flow reactor for the catalytic combustion of methane that occurs in coal-mine ventilation air. Two variants of heat withdrawal are analysed. The simulations show that a relation exists between the method for heat withdrawal and the asymmetry in the profiles of the catalyst temperature over half-cycles of flow reversal. Too strong asymmetry impairs the efficient utilization of the heat produced. The results reveal that the recovery of heat by hot gas withdrawal from the central part of the reactor, and then, the introduction of the gas into a boiler wherein it is cooled to about 333 K (60 degrees C) guarantee more favourable symmetry of the half-cycle profiles and much better utilization conditions than the direct withdrawal of heat from the mid-section of the reactor (central cooling). (c) 2007 Elsevier Ltd. All rights reserved.
引用
收藏
页码:2679 / 2689
页数:11
相关论文
共 21 条
[11]  
Matros Y. S., 1989, CATALYTIC PROCESSES
[12]   Control of the ignited steady state in autothermal fixed-bed reactors for catalytic combustion [J].
Nieken, Ulrich ;
Kolios, Gregorios ;
Eigenberger, Gerhart .
CHEMICAL ENGINEERING SCIENCE, 1994, 49 (24B) :5507-5518
[13]   A fully adaptive algorithm for parabolic partial differential equations in one space dimension [J].
Nowak, U ;
Frauhammer, J ;
Nieken, U .
COMPUTERS & CHEMICAL ENGINEERING, 1996, 20 (05) :547-561
[14]  
REHACEK J, 1992, CHEM ENG SCI, V47, P2897
[15]   The direct calculation of periodic states of the reverse flow reactor .2. Multiplicity and instability [J].
Salinger, AG ;
Eigenberger, G .
CHEMICAL ENGINEERING SCIENCE, 1996, 51 (21) :4915-4922
[16]  
Sapoundjiev H, 1999, HEAT RECOVERY LEAN I, P805
[17]   Deep oxidation of methane on alumina-manganese and Pt-containing catalysts [J].
Tsyrulnikov, PG ;
Sal'nikov, VS ;
Drozdov, VA ;
Noskov, AS ;
Chumakova, NA ;
Ermolaev, VK ;
Malakhova, IV .
JOURNAL OF CATALYSIS, 2001, 198 (02) :164-171
[18]  
UNGER J, 1997, COMP CHEM ENG S, V21, P5167
[19]  
VANDEROTTEN B, 2003, 200313 MI U LEID MAT
[20]  
*VDI, 1973, HEAT ATL