Development and operational stability evaluation of new three-cylinder energy recovery device for SWRO desalination system

被引：22
作者：
Sun, Zheng [1 ,2 ,3 ]
Wang, Yue [1 ,2 ,3 ]
Zhou, Jie [1 ,2 ,3 ]
Xu, Zitong [1 ,2 ,3 ]
Xu, Shichang [1 ,3 ]
机构：
[1] Tianjin Univ, Chem Engn Res Ctr, Sch Chem Engn & Technol, Tianjin 300072, Peoples R China
[2] State Key Lab Chem Engn, Tianjin 300072, Peoples R China
[3] Tianjin Key Lab Membrane Sci & Desalinat Technol, Tianjin 300072, Peoples R China
来源：
DESALINATION | 2021年 / 502卷
关键词：
SWRO; Energy recovery device; Overlap function; Pulsation; Centrifugal pump;
D O I：
10.1016/j.desal.2020.114909
中图分类号：
TQ [化学工业];
学科分类号：
0817 ;
摘要：
The energy recovery device (ERD) plays an important role in reducing energy consumption of seawater reverse osmosis (SWRO) system. However, for reciprocating-switcher energy recovery device (RS-ERD), stroke switching will cause flowrate and pressure pulsations of high and low pressure fluids, which will affect the operation stability of SWRO system. In this paper, we develop a three-cylinder energy recovery device (TC-ERD) and a matching control strategy with instantaneous overlap function to simultaneously reduce the flowrate and pressure pulsations of high and low pressure fluids. Under design capacity (30 m(3)/h) and 5.0 MPa operating pressure, the pressure pulsation amplitude of HP brine is only 0.0675 MPa, which is 86.5% lower than that of RSERD. The flowrate pulsation amplitude (0.954 m(3)/h) of LP seawater decreases by 68.2% compared with RS-ERD, while that (1.336 m(3)/h) of HP brine is approximately doubled. The doubling of HP brine flowrate pulsation arises from the fact that the actual operating point of the boost pump is much lower than its rated operating point, which can be improved by optimizing pump selection in future work. The energy recovery efficiency of the TC-ERD is as high as 97.1% at design capacity and 5.0 MPa operating pressure.
引用
收藏
页数：10
相关论文
共 26 条
[11]   Studies on leakage characteristics and efficiency of a fully-rotary valve energy recovery device by CFD simulation [J].
Liu, Ning ;
Liu, Zhongliang ;
Li, Yanxia ;
Sang, Lixia .
DESALINATION, 2017, 415 :40-48
[12]   Development and experimental studies on a fully-rotary valve energy recovery device for SWRO desalination system [J].
Liu, Ning ;
Liu, Zhongliang ;
Li, Yanxia ;
Sang, Lixia .
DESALINATION, 2016, 397 :67-74
[13]   Four billion people facing severe water scarcity [J].
Mekonnen, Mesfin M. ;
Hoekstra, Arjen Y. .
SCIENCE ADVANCES, 2016, 2 (02)
[14]   Ashkelon desalination plant - A successful challenge [J].
Sauvet-Goichon, Bruno .
DESALINATION, 2007, 203 (1-3) :75-81
[15]   Selection, operation and control of a work exchanger energy recovery system based on the Singapore project [J].
Schneider, B .
DESALINATION, 2005, 184 (1-3) :197-210
[16]   Development and stand tests of reciprocating-switcher energy recovery device for SWRO desalination system [J].
Song, Daiwang ;
Wang, Yue ;
Lu, Naiyuan ;
Liu, Hui ;
Xu, Enle ;
Xu, Shichang .
DESALINATION AND WATER TREATMENT, 2015, 54 (06) :1519-1525
[17]   Analysis, experiment and application of a power-saving actuator applied in the piston type energy recovery device [J].
Song, Daiwang ;
Wang, Yue ;
Xu, Shichang ;
Gao, Jianpeng ;
Ren, Yafei ;
Wang, Shichang .
DESALINATION, 2015, 361 :65-71
[18]   Control logic and strategy for emergency condition of piston type energy recovery device [J].
Song, Daiwang ;
Wang, Yue ;
Xu, Shichang ;
Wang, Zhaocheng ;
Liu, Hui ;
Wang, Shichang .
DESALINATION, 2014, 348 :1-7
[19]   Seawater reverse osmosis with isobaric energy recovery devices [J].
Stover, Richard L. .
DESALINATION, 2007, 203 (1-3) :168-175
[20]   Development of a fourth generation energy recovery device. A 'CTO's Notebook' [J].
Stover, RL .
DESALINATION, 2004, 165 (1-3) :313-321
123