Struvite Precipitation Using Continuous Flow Reactor

被引:3
|
作者
Purnomo, Chandra Wahyu [1 ,2 ]
Marpaung, Yohanes Nico [1 ]
Sreyvich, Sieng [1 ]
Fadlilah, Ilma [1 ]
Petrus, Himawan Tri Bayu Murti [1 ]
机构
[1] Gadjah Mada Univ, Dept Chem Engn, Fac Engn, Jl Grafika 2, Yogyakarta 55281, Indonesia
[2] PIAT UGM, Agrotechnol Innovat Ctr, Sleman, Yogyakarta, Indonesia
来源
11TH REGIONAL CONFERENCE ON CHEMICAL ENGINEERING (RCCHE 2018) | 2019年 / 2085卷
关键词
WASTE-WATER; PHOSPHORUS; REMOVAL; MANURE;
D O I
10.1063/1.5094983
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
Due to population rapid growth, fertilizer industries have to increase the production to ensure food security causing faster non-renewable resource depletion. However, organic wastewater (cow urine) commonly contains high amount in NH4+ and PO43- is still underutilized and causing eutrophication and unpleasant odour problem. Struvite precipitation, a common technique using for nitrogen and phosphorus recovery from wastewater, is proposed to recover the organic and renewable nutrients sources. Struvite precipitation process for nutrients recovery/removal from waste sources is beneficial not only providing slow-releasing and high-quality fertilizer but also reducing soil and water pollution from rich-nutrients wastewater. This research aimed to utilize the cow urine wastes as the raw material for the struvite precipitation, to determine the influence of the PO43-: Mg2+ concentration, and input flowrate on a continuous reactor to the struvite formation. Struvite was made using continuous method with variation of the PO43-: Mg2+ concentrations ratio of 1:1; 1:2 and 1:4 and the inlet flowrate of 8.2 mL/s and 15.8 mL/s. The results of this study show that the increase of MgCl2 addition and the higher flow rate could increase the P removal efficiency of struvite in reactors. The optimum phosphate removal efficiency at the flow rate of 8.2 mL/s is obtained at 80 mins with the percentage of 54%, while at the flow rate of 15.8 mL/s, 43% of P removal is obtained at 70 mins. The results from the kinetic study in the input flowrate was found that the higher the concentration ratio of PO43- and Mg2+, the greater the value of the reaction rate constant. However, for molar ratio 1:1 of PO43-: Mg2+, the greater the input flow rate, the smaller value of the reaction rate constant was obtained. From this study, it is revealed that the molar ratio of PO43-: Mg2+ and aeration rate affect significantly the struvite precipitation.
引用
收藏
页数:8
相关论文
共 50 条
  • [1] SYNTHESIS OF STRUVITE USING A VERTICAL CANTED REACTOR WITH CONTINUOUS LAMINAR FLOW PROCESS
    Sutiyono, S.
    Edahwati, L.
    Muryanto, S.
    Jamari, J.
    Bayuseno, A. P.
    2ND INTERNATIONAL JOINT CONFERENCE ON SCIENCE AND TECHNOLOGY (IJCST) 2017, 2018, 953
  • [2] Postdigestion struvite precipitation using a fluidized bed reactor
    Ohlinger, KN
    Young, TM
    Schroeder, ED
    JOURNAL OF ENVIRONMENTAL ENGINEERING-ASCE, 2000, 126 (04): : 361 - 368
  • [3] Continuous precipitation of antibodies using oscillatory flow reactor: A proof of concept
    Ferreira-Faria, Diogo
    Domingos-Moreira, Filipa
    Aires-Barros, M. Raquel
    Ferreira, Antonio
    Azevedo, Ana M.
    SEPARATION AND PURIFICATION TECHNOLOGY, 2023, 317
  • [4] PERFORMANCE OF A PILOT-SCALE AIR SPARGED CONTINUOUS FLOW REACTOR AND HYDROCYCLONE FOR STRUVITE PRECIPITATION AND REMOVAL FROM LIQUID SWINE MANURE
    Shepherd, T. A.
    Burns, R. T.
    Raman, D. R.
    Moody, L. B.
    Stalder, K. J.
    APPLIED ENGINEERING IN AGRICULTURE, 2009, 25 (02) : 257 - 267
  • [5] Continuous precipitation of calcium carbonate using sonochemical reactor
    Shirsath, S. R.
    Sonawane, S. H.
    Saini, D. R.
    Pandit, A. B.
    ULTRASONICS SONOCHEMISTRY, 2015, 24 : 132 - 139
  • [6] Study on Struvite Precipitation in a Mechanically Stirring Fluidized Bed Reactor
    Doino, Vincenzo
    Mozet, Kevin
    Muhr, Herve
    Plasari, Edouard
    ICHEAP-10: 10TH INTERNATIONAL CONFERENCE ON CHEMICAL AND PROCESS ENGINEERING, PTS 1-3, 2011, 24 : 679 - 684
  • [7] Influence of Ammonia Concentration on Struvite Production and Ammonia Removal Efficiency in Continuous Flow Crystallizer Reactor
    Ulfa, Raudhatul
    Machdar, Izarul
    Yunardi, Yunardi
    Suhendrayatna
    JOURNAL OF ECOLOGICAL ENGINEERING, 2024, 25 (12): : 83 - 92
  • [8] DEVELOPMENT OF A BENCH-SCALE AIR SPARGED CONTINUOUS FLOW REACTOR FOR STRUVITE PRECIPITATION FROM TWO DIFFERENT LIQUID SWINE MANURE STORAGE SYSTEMS
    Shepherd, T. A.
    Burns, R. T.
    Moody, L. B.
    Raman, D. R.
    Stalder, K. J.
    APPLIED ENGINEERING IN AGRICULTURE, 2009, 25 (03) : 425 - 430
  • [9] Continuous-Flow Precipitation of Hydroxyapatite at 37 °C in a Meso Oscillatory Flow Reactor
    Castro, Filipa
    Ferreira, Antonio
    Rocha, Fernando
    Vicente, Antonio
    Teixeira, Jose Antonio
    INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH, 2013, 52 (29) : 9816 - 9821
  • [10] Monitoring dissolved orthophosphate in a struvite precipitation reactor with a voltammetric electronic tongue
    Aguado, Daniel
    Barat, Ramon
    Soto, Juan
    Martinez-Manez, Ramon
    TALANTA, 2016, 159 : 80 - 86