Experimental investigation into pulverized-coal combustion performance and NO formation using sub-stoichiometric ratios

被引：19
作者：
Chen, Zhichao [1 ]
Wang, Zhenwang [1 ]
Li, Zhengqi [1 ]
Xie, Yiquan [1 ]
Ti, Shuguang [1 ]
Zhu, Qunyi [1 ]
机构：
[1] Harbin Inst Technol, Sch Energy Sci & Engn, Harbin 150001, Peoples R China
来源：
ENERGY | 2014年 / 73卷
基金：
中国国家自然科学基金;
关键词：
Pulverized coal; Stoichiometric ratio; NOx; Swirl burner; ASH FUSION TEMPERATURES; FIRED FURNACE; EMISSIONS; BURNOUT; BOILER; IMPACT; CARBON;
D O I：
10.1016/j.energy.2014.06.093
中图分类号：
O414.1 [热力学];
学科分类号：
摘要：
The influence of using sub-stoichiometric ratios on pulverized-coal combustion and NO formation and reduction in a pulverized-coal combustion test system with a swirl burner was investigated. Local gas components, gas temperature, the char burnout rate, and carbon and nitrogen release rates were measured at different positions in the test facility. A method for determining the fuel-rich zone boundary within the swirl pulverized-coal flame is proposed, and a new parameter, for scaling the degree of released fuel-N conversion to NO is defined. The maximum NO concentration was at the boundary between the primary-air and secondary-air jets along the cross-sections near the burner, at different stoichiometric ratios. The overall NO emission concentration decreased from 661.89 mg/N m(3) (at 6% O-2) to 169.99 mg/N m(3) (also at 6% O-2) when the stoichiometric ratio decreased from 1.0 to 0.7. The conversion of released fuel-N to NO dominated the overall NO emissions at sub-stoichiometric ratios. Decreasing the stoichiometric ratio did not significantly affect the ignition performance of the burner, but the position of the flame center moved downstream and the slagging tendency increased. (C) 2014 Elsevier Ltd. All rights reserved.
引用
收藏
页码：844 / 855
页数：12
相关论文
共 22 条
[1]   A review of the kinetics of the nitric oxide carbon reaction [J].
Aarna, I ;
Suuberg, EM .
FUEL, 1997, 76 (06) :475-491
[2]   NOX FORMATION AND REDUCTION-MECHANISMS IN PULVERIZED COAL FLAMES [J].
ABBAS, T ;
COSTA, M ;
COSTEN, P ;
GODOY, S ;
LOCKWOOD, FC ;
OU, JJ ;
ROMOMILLARES, C ;
ZHOU, J .
FUEL, 1994, 73 (09) :1423-1436
[3]   The influence of fuel bias in the primary air duct on the gas/particle flow characteristics near the swirl burner region [J].
Chen, Zhichao ;
Li, Zhengqi ;
Jing, Jianping ;
Wang, Fuqiang ;
Chen, Lizhe ;
Wu, Shaohua .
FUEL PROCESSING TECHNOLOGY, 2008, 89 (10) :958-965
[4]   Concentrator performance within a centrally fuel-rich primary air burner: Influence of multiple levels [J].
Chen, Zhichao ;
Li, Zhengqi ;
Zhu, Qunyi ;
Yang, Lianjie ;
Chen, Lizhe .
ENERGY, 2011, 36 (07) :4041-4047
[5]   Gas/particle flow and combustion characteristics and NOx emissions of a new swirl coal burner [J].
Chen, Zhichao ;
Li, Zhengqi ;
Zhu, Qunyi ;
Jing, Jianping .
ENERGY, 2011, 36 (02) :709-723
[6]   Measurements of gas species, temperature, and char burnout in a low-NOx pulverized-coal-fired utility boiler [J].
Costa, M ;
Silva, P ;
Azevedo, JLT .
COMBUSTION SCIENCE AND TECHNOLOGY, 2003, 175 (02) :271-289
[7]   Emission characteristics of NOx and unburned carbon in fly ash during combustion of blends of bituminous/sub-bituminous coals [J].
Ikeda, M ;
Makino, H ;
Morinaga, H ;
Higashiyama, K ;
Kozai, Y .
FUEL, 2003, 82 (15-17) :1851-1857
[8]   Measurement of Gas Species, Temperatures, Coal Burnout, and Wall Heat Fluxes in a 200 MWe Lignite-Fired Boiler with Different Overfire Air Damper Openings [J].
Jing, Jianping ;
Li, Zhengqi ;
Liu, Guangkui ;
Chen, Zhichao ;
Liu, Chunlong .
ENERGY & FUELS, 2009, 23 (07) :3573-3585
[9]   Effect of the Air Temperature on Combustion Characteristics and NOx Emissions from a 0.5 MW Pulverized Coal-Fired Furnace with Deep Air Staging [J].
Li, Zhengqi ;
Liu, Yong ;
Chen, Zhichao ;
Zhu, Qunyi ;
Jia, Jinzhao ;
Li, Jing ;
Wang, Zhenwang ;
Qin, Yukun .
ENERGY & FUELS, 2012, 26 (04) :2068-2074
[10]   The characterization of coal quality from the Jining coalfield [J].
Liu, GJ ;
Zheng, LG ;
Gao, LF ;
Zhang, HY ;
Peng, ZC .
ENERGY, 2005, 30 (10) :1903-1914
123