Corrosion properties of glassy Mg70Al15Ga15 in 0.1 M NaCl solution

被引：18

作者：

Uhlenhaut, D. I. ^{[1
]}

Furrer, A. ^{[1
]}

Uggowitzer, P. J. ^{[1
]}

Loeffler, J. F. ^{[1
]}

机构：

[1] ETH, Lab Met Phys & Technol, Dept Mat, CH-8093 Zurich, Switzerland

来源：

INTERMETALLICS | 2009年 / 17卷 / 10期

关键词：

Glasses; metallic; Rapid solidification processing; Corrosion; Surface properties; Electrochemical characterization; MELT-SPUN MG; AMORPHOUS-ALLOYS; METALLIC GLASSES; MAGNESIUM ALLOYS; STAINLESS-STEELS; BEHAVIOR; PASSIVITY; ALUMINUM; STABILITY; CHLORIDE;

D O I：

10.1016/j.intermet.2009.03.009

中图分类号：

O64 [物理化学（理论化学）、化学物理学];

学科分类号：

070304 ; 081704 ;

摘要：

The corrosion behavior of glassy Mg70Al15Ga15 was investigated in 0.1 M NaCl solutions of various pH values. Potentiodynamic polarization measurements confirm a pronounced passivity for 4 <= pH <= 12. Corrosion currents in neutral solutions are found to be as low as 10(-6) A/cm(2). Optical microscopy and Auger electron spectroscopy were performed on samples immersed under open-circuit conditions in neutral, acidic and alkaline 0.1 M NaCl solutions to observe their time-dependent passive film formation. A significant incorporation of aluminum in the surface layers was found. The alloys show an unusual stability against dissolution in chloride-containing solutions, raising expectations of a highly corrosion-resistant Mg-based alloy. The time-dependent limitations of this stability are discussed in context with the surface films observed. (C) 2009 Elsevier Ltd. All rights reserved.

引用

页码：811 / 817

页数：7

共 50 条

[41] Effect of Ga content in Al-9 mass%Mg alloys on local corrosion in H2SO4-NaCl solution
Toriyama, S
Mae, T
Arai, K
JOURNAL OF THE JAPAN INSTITUTE OF METALS, 1997, 61 (04) : 334 - 341
[42] CORROSION INVESTIGATIONS OF Al-Si CASTING ALLOYS IN 0.6 M NaCl SOLUTION
Hanza, Suncana Smokvina
Vrsalovic, Ladislav
Stic, Lovro
Liveric, Lovro
ENGINEERING REVIEW, 2021, 41 (03) : 115 - 123
[43] The effect of solution temperature on the microstructure and tensile properties of Al-15%Mg2Si composite
Malekan, A.
Emamy, M.
Rassizadehghani, J.
Emami, A. R.
MATERIALS & DESIGN, 2011, 32 (05) : 2701 - 2709
[44] Propolis extract as corrosion inhibitor of iron alloy immersed in an ethylene glycol/water, 0.1 m NaCl solution
Hachelef H.
Khelifa A.
Benmoussat A.
Defect and Diffusion Forum, 2021, 406 : 265 - 273
[45] TRANSPORT-PROPERTIES OF AL65CU15CO20 AND AL70NI15CO15 DECAGONAL QUASI-CRYSTALS
MARTIN, S
HEBARD, AF
KORTAN, AR
THIEL, FA
PHYSICAL REVIEW LETTERS, 1991, 67 (06) : 719 - 722
[46] Studies on galvanic corrosion of iron-magnesium couple by scanning electrochemical microscopy in 0.1 M NaCl solution
Raj, X. Joseph
Nishimura, T.
JOURNAL OF INDUSTRIAL AND ENGINEERING CHEMISTRY, 2016, 41 : 141 - 150
[47] Effect of cerium-based conversion coating on corrosion behavior of squeeze cast Mg-4 wt% Y alloy in 0.1 M NaCl solution
Kamde, Meeta Ashok
Mahton, Yogendra
Ohodnicki, John
Roy, Mangal
Saha, Partha
SURFACE & COATINGS TECHNOLOGY, 2021, 421
[48] Effect of cerium-based conversion coating on corrosion behavior of squeeze cast Mg-4 wt% Y alloy in 0.1 M NaCl solution
Kamde, Meeta Ashok
Mahton, Yogendra
Ohodnicki, John
Roy, Mangal
Saha, Partha
Surface and Coatings Technology, 2021, 421
[49] Corrosion behavior of Al-3.0 wt%Mg alloy in NaCl solution under magnetic field
Xin Zhang
Ze-Hua Wang
Ze-Hua Zhou
Jian-Ming Xu
Zhao-Jun Zhong
Huan-Long Yuan
RareMetals, 2017, 36 (08) : 627 - 634
[50] Corrosion behavior of Al-3.0 wt% Mg alloy in NaCl solution under magnetic field
Zhang, Xin
Wang, Ze-Hua
Zhou, Ze-Hua
Xu, Jian-Ming
Zhong, Zhao-Jun
Yuan, Huan-Long
RARE METALS, 2017, 36 (08) : 627 - 634

← 1 2 3 4 5 →