Experimental investigation of heat transfer and pressure drop of turbulent flow inside tube with inserted helical coils

被引：25
|
作者：
Sharafeldeen, M. A. [1 ]
Berbish, N. S. [1 ]
Moawed, M. A. [1 ]
Ali, R. K. [1 ]
机构：
[1] Benha Univ, Fac Engn Shoubra, Dept Mech Engn, 108 Shoubra St, Cairo 11689, Egypt
来源：
HEAT AND MASS TRANSFER | 2017年 / 53卷 / 04期
关键词：
WIRE INSERTS; TRANSFER ENHANCEMENT; EXCHANGER DESIGN; PERFORMANCE; LAMINAR; SURFACES; REGIMES;
D O I：
10.1007/s00231-016-1897-z
中图分类号：
O414.1 [热力学];
学科分类号：
摘要：
The heat transfer and pressure drop were experimentally investigated in a coiled wire inserted tube in turbulent flow regime in the range of Reynolds number of 14,400 Re 42,900. The present work aims to extend the experimental data available on wire coil inserts to cover wire diameter ratio of 0.044 e/d 0.133 and coil pitch ratio of 1 p/d 5. Uniform heat flux was applied to the external surface of the tube and air was selected as fluid. The effects of Reynolds number and wire diameter and coil pitch ratios on the Nusselt number and friction factor were studied. The enhancement efficiency and performance criteria ranges are of (46.9-82.6 %) and (100.1-128 %) within the investigated range of the different parameters, respectively. Correlations are obtained for the average Nusselt number and friction factor utilizing the present measurements within the investigated range of geometrical parameters and Re. The maximum deviation between correlated and experimental values for Nusselt number and friction factor are +/- 5 and +/- 6 %, respectively.
引用
收藏
页码：1265 / 1276
页数：12
相关论文
共 50 条
  • [31] Heat transfer and pressure drop in a heat exchanger with a helical pipe containing inside springs
    Yildiz, C
    Bicer, Y
    Pehlivan, D
    ENERGY CONVERSION AND MANAGEMENT, 1997, 38 (06) : 619 - 624
  • [32] Boiling pressure drop and local heat transfer distribution of helical coils with water at low pressure
    Hardik, B. K.
    Prabhu, S. V.
    INTERNATIONAL JOURNAL OF THERMAL SCIENCES, 2017, 114 : 44 - 63
  • [33] EXPERIMENTAL INVESTIGATION OF LOCAL HEAT TRANSFER AND PRESSURE DROP DURING COOLING OF A GAS IN A TUBE
    ARTAMONO.NI
    DANILOV, YI
    DREITSER, GA
    KALININ, EK
    INTERNATIONAL CHEMICAL ENGINEERING, 1971, 11 (03): : 502 - &
  • [34] HEAT TRANSFER AND PRESSURE DROP IN SINGLE PHASE TURBULENT FLOW INSIDE INTERNALLY HELICAL-GROOVED HORIZONTAL SMALL-DIAMETER TUBES
    Inoue, N.
    Ichinose, J.
    23RD IIR INTERNATIONAL CONGRESS OF REFRIGERATION, 2011, 23 : 2721 - 2728
  • [35] Experimental investigation on heat transfer and pressure drop of internal flow in corrugated tubes
    Andrade, F.
    Moita, A. S.
    Nikulin, A.
    Moreira, A. L. N.
    Santos, H.
    INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2019, 140 : 940 - 955
  • [36] An experimental investigation of the frictional pressure drop of steam-water two-phase flow in helical coils
    Guo, LJ
    Feng, ZP
    Chen, XJ
    INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2001, 44 (14) : 2601 - 2610
  • [37] Experimental study of turbulent flow heat transfer and pressure drop in a plate heat exchanger with chevron plates
    Muley, A
    Manglik, RM
    JOURNAL OF HEAT TRANSFER-TRANSACTIONS OF THE ASME, 1999, 121 (01): : 110 - 117
  • [38] Experimental studies on heat transfer to Newtonian and non-Newtonian fluids in helical coils with laminar and turbulent flow
    Pawar, S. S.
    Sunnapwar, Vivek K.
    EXPERIMENTAL THERMAL AND FLUID SCIENCE, 2013, 44 : 792 - 804
  • [39] Experimental investigation of heat transfer and pressure drop in a mini-channel shell and tube heat exchanger
    Unverdi, Murat
    Kucuk, Hasan
    Yilmaz, Mehmet Senan
    HEAT AND MASS TRANSFER, 2019, 55 (05) : 1271 - 1286
  • [40] Al/oil nanofluids inside annular tube: an experimental study on convective heat transfer and pressure drop
    Jafarimoghaddam, Amin
    Aberoumand, Sadegh
    Javaherdeh, Kourosh
    Arani, Ali Akbar Abbasian
    Jafarimoghaddam, Reza
    HEAT AND MASS TRANSFER, 2018, 54 (04) : 1053 - 1067
12345