Electrochemical deposition and corrosion stability of Zn-Co alloys

被引：34

作者：

Bajat, J. B. ^{[1
]}

Stankovic, S. ^{[1
]}

Jokic, B. M. ^{[1
]}

机构：

[1] Univ Belgrade, Fac Technol & Met, Belgrade 11120, Serbia

来源：

JOURNAL OF SOLID STATE ELECTROCHEMISTRY | 2009年 / 13卷 / 05期

关键词：

Electrodeposition; Zn-Co alloy; ALSV; Phase structure; Corrosion; ZINC-NICKEL ALLOYS; ELECTRODEPOSITED ZN; PROTECTIVE ABILITY; COBALT ALLOY; NI ALLOYS; COATINGS; BEHAVIOR; RESISTANCE;

D O I：

10.1007/s10008-008-0604-5

中图分类号：

O646 [电化学、电解、磁化学];

学科分类号：

081704 ;

摘要：

Electrochemically deposited Zn-Co alloys under various deposition conditions were investigated using anodic linear sweep voltammetry for phase structure determination, scanning electron microscopy for surface morphology analysis, atomic absorption spectroscopy for determination of chemical composition, and polarization measurements and open circuit potential measurements for determination of corrosion properties. The influence of deposition current density, temperature, and composition of deposition solution on the phase structure and corrosion properties of Zn-Co alloys was studied. It was shown that the ratio of cobalt to zinc ions in the plating bath strongly affects the chemical content and phase structure, as well as corrosion stability, of Zn-Co alloys. Zn-Co alloys deposited from plating baths with the lowest and the highest ratios of cobalt and zinc ions exhibited the lowest corrosion rate.

引用

页码：755 / 762

页数：8

共 26 条

[1] Electrodeposition of Zn-Ni alloys from sulfate bath [J].

Abou-Krisha, M. M. ;

Assaf, F. H. ;

Toghan, A. A. .

JOURNAL OF SOLID STATE ELECTROCHEMISTRY, 2007, 11 (02) :244-252

[2]

American Society for Metals, 1973, MET HDB MET STRUCT P, V8

[3] Electrochemical deposition and characterization of Zn-Co alloys and corrosion protection by electrodeposited epoxy coating on Zn-Co alloy [J].

Bajat, JB ;

Miskovic-Stankovic, VB ;

Maksimovic, MD ;

Drazic, DM ;

Zec, S .

ELECTROCHIMICA ACTA, 2002, 47 (25) :4101-4112

[4] Electrochemical deposition and characterization of zinc-nickel alloys deposited by direct and pulse current [J].

Bajat, JB ;

Maksimovic, MD ;

Radovic, GR .

JOURNAL OF THE SERBIAN CHEMICAL SOCIETY, 2002, 67 (8-9) :625-634

[5] Influence of the alloying component on the protective ability of some zinc galvanic coatings [J].

Boshkov, N ;

Petrov, K ;

Kovacheva, D ;

Vitkova, S ;

Nemska, S .

ELECTROCHIMICA ACTA, 2005, 51 (01) :77-84

[6] Composition of the corrosion products of galvanic alloys Zn-Co and their influence on the protective ability [J].

Boshkov, N ;

Petrov, K ;

Vitkova, S ;

Nemska, S ;

Raichevsky, G .

SURFACE & COATINGS TECHNOLOGY, 2002, 157 (2-3) :171-178

[7]

Brenner A., 1963, Electrodeposition of Alloys, V2, P194

[8] Electrodeposition of cobalt and zinc-cobalt alloys from a lewis acidic zinc chloride-1-ethyl-3 methylimidazolium chloride molten salt [J].

Chen, PY ;

Sun, IW .

ELECTROCHIMICA ACTA, 2001, 46 (08) :1169-1177

[9]

Despic A.R., 1995, Modern Aspects of Electrochemistry, V27, P143, DOI [DOI 10.1007/978-1-4899-1724-9-2, 10.1007/978-1-4899-1724-9-2.]

[10] Dependence of coating characteristics on deposition potential for electrodeposited Zn-Ni alloys [J].

Elkhatabi, F ;

Benballa, M ;

Sarret, M ;

Müller, C .

ELECTROCHIMICA ACTA, 1999, 44 (10) :1645-1653

← 1 2 3 →