Corrosion resistance of HVOF-sprayed Ni2Si intermetallic coatings in hot H2SO4 medium

被引：6
|
作者：
Verdian, M. M. [1 ]
Raeissi, K. [1 ]
Salehi, M. [1 ]
机构：
[1] Isfahan Univ Technol, Dept Mat Engn, Esfahan 8415683111, Iran
来源：
SURFACE & COATINGS TECHNOLOGY | 2014年 / 240卷
关键词：
Corrosion; EIS; Mott-Schottky; H2SO4; Ni2Si; HVOF; STEEL;
D O I：
10.1016/j.surfcoat.2013.12.016
中图分类号：
TB3 [工程材料学];
学科分类号：
0805 ; 080502 ;
摘要：
Corrosion behavior of high velocity oxy-fuel (HVOF) Ni2Si intermetallic coatings was investigated by means of Tafel polarization tests and electrochemical impedance spectroscopy (EIS) measurements in 70% H2SO4 solutions at 75 degrees C. Mott-Schottky analysis was also carried out to investigate semiconductive properties of passive films. It was found that the corrosion rate of HVOF Ni2Si coating was much lower than that of stainless steel substrate. Both Ni2Si bulk and coating materials showed an active-passive behavior with a wide passive range during anodic polarization. EIS measurements at open circuit conditions revealed that the system showed one time constant at low frequencies which was attributed to charge transfer processes. Under passive conditions, one time constant was observed at high frequencies which was related to formation of passive films. Further investigation showed that passive film formed on Ni2Si materials in H2SO4 is a p-type semiconductor with acceptor density in the order of 1020 cm(-3). (C) 2013 Elsevier B.V. All rights reserved.
引用
收藏
页码：70 / 75
页数：6
相关论文
共 50 条
  • [41] Characterization and High-Temperature Fretting Wear Resistance of HVOF-Sprayed Cr3C2-NiCr, CoCrWC and CoCrWNiC Hardfacing Coatings
    Zamani, Pejman
    Ghasemi, Reza
    Torabi, Shahla
    Mirjani, Behta
    Memari, Mahmood
    Alizadeh, Mohammad
    Khaledi, Hiwa
    JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2022, 31 (07) : 2157 - 2171
  • [42] SYNTHESIS, CHARACTERIZATION AND INVESTIGATION OF SCHIFF BASE AS A CORROSION INHIBITOR FOR MILD STEEL IN H2SO4 MEDIUM
    Yadav, Ompal Singh
    Kumar, Sudershan
    Kaur, Gurmeet
    Singh, Gurmeet
    HETEROCYCLIC LETTERS, 2014, 4 (02): : 287 - 293
  • [43] Electrochemical corrosion behavior of electroless Ni-P coating in NaCl and H2SO4 solutions
    Wang, L. L.
    Chen, H. J.
    Hao, L.
    Lin, A.
    Gan, F. X.
    MATERIALS AND CORROSION-WERKSTOFFE UND KORROSION, 2011, 62 (11): : 1003 - 1007
  • [44] Inhibition by Ginkgo leaves extract of the corrosion of steel in HCl and H2SO4 solutions
    Deng, Shuduan
    Li, Xianghong
    CORROSION SCIENCE, 2012, 55 : 407 - 415
  • [45] Thiophene derivatives as effective inhibitors for the corrosion of steel in 0.5 m H2SO4
    M. Bouklah
    B. Hammouti
    M. Benkaddour
    T. Benhadda
    Journal of Applied Electrochemistry, 2005, 35 : 1095 - 1101
  • [46] Inhibition of the corrosion of steel in HCl, H2SO4 solutions by bamboo leaf extract
    Li, Xianghong
    Deng, Shuduan
    Fu, Hui
    CORROSION SCIENCE, 2012, 62 : 163 - 175
  • [47] Thiophene derivatives as effective inhibitors for the corrosion of steel in 0.5 M H2SO4
    Bouklah, M
    Hammouti, B
    Aouniti, A
    Benhadda, T
    PROGRESS IN ORGANIC COATINGS, 2004, 49 (03) : 225 - 228
  • [48] Thiophene derivatives as effective inhibitors for the corrosion of steel in 0.5 M H2SO4
    Bouklah, M
    Hammouti, B
    Benkaddour, M
    Benhadda, T
    JOURNAL OF APPLIED ELECTROCHEMISTRY, 2005, 35 (11) : 1095 - 1101
  • [49] Corrosion Inhibition of Carbon Steel in H2SO4 By Chenopodium Ambrosioides
    Rodriguez-Clemente, E.
    Gonzalez-Rodriguez, J. G.
    Valladarez, G.
    Dominguez-Patino, G. F.
    INTERNATIONAL JOURNAL OF ELECTROCHEMICAL SCIENCE, 2011, 6 (12): : 6360 - 6372
  • [50] The Inhibition of Carbon Steel Corrosion by Lignin in HCl and H2SO4
    Yahya, S.
    Othman, N. K.
    Daud, A. R.
    Jalar, A.
    2013 UKM FST POSTGRADUATE COLLOQUIUM, 2013, 1571 : 132 - 135
12345