Corrosion resistance of HVOF-sprayed Ni2Si intermetallic coatings in hot H2SO4 medium

被引：6
|
作者：
Verdian, M. M. [1 ]
Raeissi, K. [1 ]
Salehi, M. [1 ]
机构：
[1] Isfahan Univ Technol, Dept Mat Engn, Esfahan 8415683111, Iran
来源：
SURFACE & COATINGS TECHNOLOGY | 2014年 / 240卷
关键词：
Corrosion; EIS; Mott-Schottky; H2SO4; Ni2Si; HVOF; STEEL;
D O I：
10.1016/j.surfcoat.2013.12.016
中图分类号：
TB3 [工程材料学];
学科分类号：
0805 ; 080502 ;
摘要：
Corrosion behavior of high velocity oxy-fuel (HVOF) Ni2Si intermetallic coatings was investigated by means of Tafel polarization tests and electrochemical impedance spectroscopy (EIS) measurements in 70% H2SO4 solutions at 75 degrees C. Mott-Schottky analysis was also carried out to investigate semiconductive properties of passive films. It was found that the corrosion rate of HVOF Ni2Si coating was much lower than that of stainless steel substrate. Both Ni2Si bulk and coating materials showed an active-passive behavior with a wide passive range during anodic polarization. EIS measurements at open circuit conditions revealed that the system showed one time constant at low frequencies which was attributed to charge transfer processes. Under passive conditions, one time constant was observed at high frequencies which was related to formation of passive films. Further investigation showed that passive film formed on Ni2Si materials in H2SO4 is a p-type semiconductor with acceptor density in the order of 1020 cm(-3). (C) 2013 Elsevier B.V. All rights reserved.
引用
收藏
页码：70 / 75
页数：6
相关论文
共 50 条
  • [31] Hot Corrosion Behaviour of HVOF Sprayed (Cr3C2–35 % NiCr) + 5 % Si Coatings in the Presence of Na2SO4–60 % V2O5 at 700 °C
    B. Somasundaram
    Ravikiran Kadoli
    M. R. Ramesh
    Transactions of the Indian Institute of Metals, 2015, 68 : 257 - 268
  • [32] Assessment of Sulfide Corrosion and Wear Behavior of HVOF-Sprayed Cr3C2-25NiCr Coating on 304 Stainless Steels in H2S Environment
    Huang, Chenhao
    Wang, Jun
    Yan, Jing
    Li, Longyi
    TRANSACTIONS OF THE INDIAN INSTITUTE OF METALS, 2023, 76 (12) : 3219 - 3228
  • [33] Study on the Inhibition of Mild Steel Corrosion by Benzoisoxazole and Benzopyrazole Derivatives in H2SO4 Medium
    Parameswari, K.
    Rekha, S.
    Chitra, S.
    Kayalvizhy, E.
    PORTUGALIAE ELECTROCHIMICA ACTA, 2010, 28 (03) : 189 - 201
  • [34] PHYTOCHEMICALS AND INHIBITIVE PROPERTIES OF CASHEW EXTRACT AS CORROSION INHIBITOR OF ALUMINIUM IN H2SO4 MEDIUM
    Omotioma, M.
    Onukwuli, O. D.
    Obiora-Okafo, I
    LATIN AMERICAN APPLIED RESEARCH, 2019, 49 (02) : 99 - 103
  • [35] Performance Analysis of Cavitation Erosion Resistance and Corrosion Behavior of HVOF-Sprayed WC-10Co-4Cr, WC-12Co, and Cr3C2-NiCr Coatings
    Ji Liu
    Tongzhou Chen
    Chengqing Yuan
    Xiuqin Bai
    Journal of Thermal Spray Technology, 2020, 29 : 798 - 810
  • [36] Performance Analysis of Cavitation Erosion Resistance and Corrosion Behavior of HVOF-Sprayed WC-10Co-4Cr, WC-12Co, and Cr3C2-NiCr Coatings
    Liu, Ji
    Chen, Tongzhou
    Yuan, Chengqing
    Bai, Xiuqin
    JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2020, 29 (04) : 798 - 810
  • [37] Electrochemical corrosion of silicon carbide ceramics in H2SO4
    Herrmann, Mathias
    Sempf, Kerstin
    Schneider, Michael
    Sydow, Uwe
    Kremmer, Kerstin
    Michaelis, Alexander
    JOURNAL OF THE EUROPEAN CERAMIC SOCIETY, 2014, 34 (02) : 229 - 235
  • [38] CORROSION BEHAVIOR OF PURE CHROMIUM IN H2SO4 SOLUTIONS
    KATO, M
    SAKAKI, T
    JOURNAL OF THE JAPAN INSTITUTE OF METALS, 1992, 56 (01) : 67 - 73
  • [39] Corrosion performance of a rapidly solidified NiAl intermetallic macroallolled with Fe in 0.5M H2SO4
    Colin, J.
    Serna, S.
    Campillo, B.
    Florez, O.
    Gonzalez-Rodriguez, J. G.
    INTERNATIONAL JOURNAL OF ELECTROCHEMICAL SCIENCE, 2007, 2 (12): : 947 - 957
  • [40] Niobium addition enhancing the corrosion resistance of nanocrystalline Ti5Si3 coating in H2SO4 solution
    Xu, J.
    Liu, L.
    Li, Z.
    Munroe, P.
    Xie, Z. -H.
    ACTA MATERIALIA, 2014, 63 : 245 - 260
12345