Corrosion resistance of HVOF-sprayed Ni2Si intermetallic coatings in hot H2SO4 medium

被引：6
|
作者：
Verdian, M. M. [1 ]
Raeissi, K. [1 ]
Salehi, M. [1 ]
机构：
[1] Isfahan Univ Technol, Dept Mat Engn, Esfahan 8415683111, Iran
来源：
SURFACE & COATINGS TECHNOLOGY | 2014年 / 240卷
关键词：
Corrosion; EIS; Mott-Schottky; H2SO4; Ni2Si; HVOF; STEEL;
D O I：
10.1016/j.surfcoat.2013.12.016
中图分类号：
TB3 [工程材料学];
学科分类号：
0805 ; 080502 ;
摘要：
Corrosion behavior of high velocity oxy-fuel (HVOF) Ni2Si intermetallic coatings was investigated by means of Tafel polarization tests and electrochemical impedance spectroscopy (EIS) measurements in 70% H2SO4 solutions at 75 degrees C. Mott-Schottky analysis was also carried out to investigate semiconductive properties of passive films. It was found that the corrosion rate of HVOF Ni2Si coating was much lower than that of stainless steel substrate. Both Ni2Si bulk and coating materials showed an active-passive behavior with a wide passive range during anodic polarization. EIS measurements at open circuit conditions revealed that the system showed one time constant at low frequencies which was attributed to charge transfer processes. Under passive conditions, one time constant was observed at high frequencies which was related to formation of passive films. Further investigation showed that passive film formed on Ni2Si materials in H2SO4 is a p-type semiconductor with acceptor density in the order of 1020 cm(-3). (C) 2013 Elsevier B.V. All rights reserved.
引用
收藏
页码：70 / 75
页数：6
相关论文
共 50 条
  • [21] Corrosion of Ni-Al and Ni-Al-Al2O3 Flame Sprayed Coatings of "CastoDyn 8000" System in 0.01 M H2SO4 and 3.5% NaCl Solutions
    Starosta, Robert
    ENVIRONMENTAL DEGRADATION OF ENGINEERING & MATERIALS ENGINEERING AND TECHNOLOGIES, 2012, 183 : 185 - 192
  • [22] Electrochemical behaviour of thermally sprayed Cr3C2-NiCr coatings in 0.5 M H2SO4 media
    Suegama, PH
    Fugivara, CS
    Benedetti, AV
    Fernández, J
    Delgado, J
    Guilemany, JM
    JOURNAL OF APPLIED ELECTROCHEMISTRY, 2002, 32 (11) : 1287 - 1295
  • [23] Electrochemical behaviour of thermally sprayed Cr3C2–NiCr coatings in 0.5 M H2SO4 media
    P.H. Suegama
    C.S. Fugivara
    A.V. Benedetti
    J. Fernández
    J. Delgado
    J.M. Guilemany
    Journal of Applied Electrochemistry, 2002, 32 : 1287 - 1295
  • [24] Investigation of the Corrosion Behavior of Mild Steel/H2SO4 Systems
    Al-Moubaraki, A. H.
    Ganash, A. A.
    Al-Malwi, S. D.
    MOROCCAN JOURNAL OF CHEMISTRY, 2020, 8 (01): : 264 - 279
  • [25] H2SO4 as a passivating medium on the localised corrosion resistance of surgical 316L SS metallic implant and its effect on hydroxyapatite coatings
    Kannan, S
    Balamurugan, A
    Rajeswari, S
    ELECTROCHIMICA ACTA, 2004, 49 (15) : 2395 - 2403
  • [26] The influence of sulphide on the ultrasonic cavitation erosion-corrosion behaviors of HVOF-sprayed WC-Cr3C2-Ni coating
    Shi, Xinlu
    Cui, Dandong
    Wei, Zheng
    Hong, Sheng
    ULTRASONICS SONOCHEMISTRY, 2023, 100
  • [27] Hot corrosion behaviour of HVOF-sprayed 93(WC-Cr3C2)-7Ni and 83WC-17Co coatings on boiler tube steel in coal fired boiler
    Sidhu, Varinder Pal Singh
    Goyal, Khushdeep
    Goyal, Rakesh
    AUSTRALIAN JOURNAL OF MECHANICAL ENGINEERING, 2019, 17 (02) : 127 - 132
  • [28] The effects of post-treatment on the hot corrosion behavior of the HVOF-sprayed Cr3C2-NiCr coating
    Chatha, Sukhpal Singh
    Sidhu, Hazoor S.
    Sidhu, Buta S.
    SURFACE & COATINGS TECHNOLOGY, 2012, 206 (19-20): : 4212 - 4224
  • [29] Monolayer and bilayer conducting polymer coatings for corrosion protection of steel in 1 M H2SO4 solution
    Hasanov, Rovshan
    Bilgic, Semra
    PROGRESS IN ORGANIC COATINGS, 2009, 64 (04) : 435 - 445
  • [30] Corrosion protection properties of Janus PTFE coatings in highly corrosive H2SO4 solutions
    Xu, Kaixin
    Sun, Wen
    Wang, Lida
    Yang, Zhengqing
    Li, Bohang
    Ma, Yunsheng
    Zhao, Liqiu
    Zhang, Chenghe
    Ma, Shiheng
    Han, Haoxue
    Liu, Guichang
    CORROSION SCIENCE, 2022, 207
12345