Corrosion resistance of HVOF-sprayed Ni2Si intermetallic coatings in hot H2SO4 medium

被引：6
|
作者：
Verdian, M. M. [1 ]
Raeissi, K. [1 ]
Salehi, M. [1 ]
机构：
[1] Isfahan Univ Technol, Dept Mat Engn, Esfahan 8415683111, Iran
来源：
SURFACE & COATINGS TECHNOLOGY | 2014年 / 240卷
关键词：
Corrosion; EIS; Mott-Schottky; H2SO4; Ni2Si; HVOF; STEEL;
D O I：
10.1016/j.surfcoat.2013.12.016
中图分类号：
TB3 [工程材料学];
学科分类号：
0805 ; 080502 ;
摘要：
Corrosion behavior of high velocity oxy-fuel (HVOF) Ni2Si intermetallic coatings was investigated by means of Tafel polarization tests and electrochemical impedance spectroscopy (EIS) measurements in 70% H2SO4 solutions at 75 degrees C. Mott-Schottky analysis was also carried out to investigate semiconductive properties of passive films. It was found that the corrosion rate of HVOF Ni2Si coating was much lower than that of stainless steel substrate. Both Ni2Si bulk and coating materials showed an active-passive behavior with a wide passive range during anodic polarization. EIS measurements at open circuit conditions revealed that the system showed one time constant at low frequencies which was attributed to charge transfer processes. Under passive conditions, one time constant was observed at high frequencies which was related to formation of passive films. Further investigation showed that passive film formed on Ni2Si materials in H2SO4 is a p-type semiconductor with acceptor density in the order of 1020 cm(-3). (C) 2013 Elsevier B.V. All rights reserved.
引用
收藏
页码：70 / 75
页数：6
相关论文
共 50 条
  • [1] Fabrication and corrosion resistance of HVOF-sprayed Ni2Si intermetallic compound
    Verdian, M. M.
    Raeissi, K.
    Salehi, M.
    APPLIED SURFACE SCIENCE, 2013, 273 : 426 - 431
  • [2] Corrosion Behavior of Ti2Ni3Si/NiTi Intermetallic Alloys in H2SO4 Solution
    Dong Lixin
    Wang Huaming
    RARE METAL MATERIALS AND ENGINEERING, 2009, 38 (06) : 1010 - 1014
  • [3] Corrosion behaviour of Ni2Si intermetallic coatings in nitric acid solutions
    Verdian, M. M.
    Raeissi, K.
    Salehi, M.
    TRANSACTIONS OF THE INSTITUTE OF METAL FINISHING, 2015, 93 (01): : 38 - 43
  • [4] Corrosion resistance of laser clad Cr-alloyed Ni2Si/NiSi intermetallic coatings
    Cai, LX
    Wang, HM
    Wang, CM
    SURFACE & COATINGS TECHNOLOGY, 2004, 182 (2-3): : 294 - 299
  • [5] A Study on Wear Resistance of HVOF-Sprayed Ni-MoS2 Self-Lubricating Composite Coatings
    Y. L. Liu
    M. C. Jeng
    J. R. Hwang
    C. H. Chang
    Journal of Thermal Spray Technology, 2015, 24 : 489 - 495
  • [6] A Study on Wear Resistance of HVOF-Sprayed Ni-MoS2 Self-Lubricating Composite Coatings
    Liu, Y. L.
    Jeng, M. C.
    Hwang, J. R.
    Chang, C. H.
    JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2015, 24 (03) : 489 - 495
  • [7] Evaluating the metallurgical and corrosion characteristics of HVOF-sprayed Ni and Ni-TiB2 coatings on duplex stainless steel
    Soundararajan, R.
    Kaviyarasan, K.
    Sathishkumar, A.
    Sivasankaran, S.
    CERAMICS INTERNATIONAL, 2025, 51 (06) : 7636 - 7650
  • [8] Electrochemical Corrosion of HVOF-Sprayed NiCoCrAlY Coatings in CO2-Saturated Brine
    H. Ruiz-Luna
    J. Porcayo-Calderon
    J. M. Alvarado-Orozco
    J. E. García-Herrera
    L. Martinez-Gomez
    L. G. Trápaga-Martínez
    J. Muñoz-Saldaña
    Journal of Thermal Spray Technology, 2016, 25 : 1330 - 1343
  • [9] Electrochemical Corrosion of HVOF-Sprayed NiCoCrAlY Coatings in CO2-Saturated Brine
    Ruiz-Luna, H.
    Porcayo-Calderon, J.
    Alvarado-Orozco, J. M.
    Garcia-Herrera, J. E.
    Martinez-Gomez, L.
    Trapaga-Martinez, L. G.
    Munoz-Saldana, J.
    JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2016, 25 (07) : 1330 - 1343
  • [10] Effect of sulphide concentration on corrosion behaviors of HVOF-sprayed WC-Cr3C2-Ni and WC-Ni coatings
    Wei, Ziyu
    Cui, Dandong
    Wei, Zheng
    Hong, Sheng
    INTERNATIONAL JOURNAL OF REFRACTORY METALS & HARD MATERIALS, 2023, 111
12345