Fabrication of NiO/SiO2 nanocomposites using sol-gel method and optimization of gelation time using Taguchi robust design method

被引：19

作者：

Kamyabi-Gol, A. ^{[1
]}

Zebarjad, S. M. ^{[1
]}

Sajjadi, S. A. ^{[1
]}

机构：

[1] Ferdowsi Univ Mashhad, Dept Mat Sci & Met Engn, Fac Engn, Mashhad, Iran

来源：

COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS | 2009年 / 336卷 / 1-3期

关键词：

Nanocomposite; Sol-gel; Nickel alloys; Taguchi; NI/SIO2; CATALYST; METHANE; FILMS; STEAM; HYDROGENATION; NIO; CO;

D O I：

10.1016/j.colsurfa.2008.11.045

中图分类号：

O64 [物理化学（理论化学）、化学物理学];

学科分类号：

070304 ; 081704 ;

摘要：

The present work deals with the synthesis of NiO/SiO2 nanocomposites fabricated by embedding nickel oxide particles, obtained from hexahydrated nickel nitrate (Ni(NO3)(2) center dot 6H(2)O), in a silica matrix, through sol-gel method based on hydrolysis and condensation of tetraethyl orthosilicate (TEOS) alkoxide. Due to the various factors, e. g. pH, EtOH/TEOS/H2O ratio, Si/Ni ratio, etc., influencing the gelation time of the solutions, Taguchi robust design method of system optimization was used to determine the percent of contribution (%rho) of each factor. It was found that the pH of the solutions had the most influence on the gelation time (68.76%) and the Si/Ni atomic ratio stood in second place (12.95%). It was illustrated that the molar ratio of EtOH/TEOS had the least influence on the gelation time. (C) 2008 Elsevier B. V. All rights reserved.

引用

页码：69 / 74

页数：6

共 26 条

[11] High-loaded nickel-silica catalysts for hydrogenation, prepared by sol-gel Route: structure and catalytic behavior
Ermakova, MA
Ermakov, DY
[J]. APPLIED CATALYSIS A-GENERAL, 2003, 245 (02) : 277 - 288
[12] Fan Q., 2008, FRONT CHEM ENG CHINA, V2, P63
[13] Formation of NiO-SiO2 nanocomposite thin films by the sol-gel method
Hernández-Torres, J
Mendoza-Galván, A
[J]. JOURNAL OF NON-CRYSTALLINE SOLIDS, 2005, 351 (24-26) : 2029 - 2035
[14] The features of thin film and ceramic sensors at the detection of CO and NO2
Ivanovskaya, M
Bogdanov, P
Faglia, G
Sberveglieri, G
[J]. SENSORS AND ACTUATORS B-CHEMICAL, 2000, 68 (1-3): : 344 - 350
[15] Hydrogenation of naphthalene over NiO/SiO2-Al2O3 catalysts:: Structure-activity correlation
Kirumakki, Sharath R.
Shpeizer, Boris G.
Sagar, Guggilla Vidya
Chary, Komandur V. R.
Clearfield, Abraham
[J]. JOURNAL OF CATALYSIS, 2006, 242 (02) : 319 - 331
[16] NiO-SiO2 sol-gel nanocomposite films for optical gas sensor
Martucci, A
Bassiri, N
Guglielmi, M
Armelao, L
Gross, S
Pivin, JC
[J]. JOURNAL OF SOL-GEL SCIENCE AND TECHNOLOGY, 2003, 26 (1-3) : 993 - 996
[17] Steam reforming of methane over nickel catalysts at low reaction temperature
Matsumura, Y
Nakamori, T
[J]. APPLIED CATALYSIS A-GENERAL, 2004, 258 (01) : 107 - 114
[18] CONVERSION DEPENDENCE OF ENANTIOSELECTIVE HYDROGENATION OF METHYL ACETOACETATE WITH MODIFIED NI-SIO2 CATALYST
NITTA, Y
SEKINE, F
SASAKI, J
IMANAKA, T
TERANISHI, S
[J]. JOURNAL OF CATALYSIS, 1983, 79 (01) : 211 - 214
[19] Roy RK, 1990, PRIMER TAGUCHI METHO
[20] Taguchi G, 1962, TABLES ORTHOGONAL AR

← 1 2 3 →