Effect of mist injection position on particle separation performance of cyclone scrubber

被引:17
作者
Yang, KS [1 ]
Yoshida, H [1 ]
机构
[1] Hiroshima Univ, Dept Chem Engn, Hiroshima 7398527, Japan
关键词
cyclone scrubber; numerical simulation; mist injection; partial separation efficiency; particle separation;
D O I
10.1016/j.seppur.2003.09.009
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
Experimental and simulation studies have been conducted about the effect of mist injection position on particle separation performance of cyclone scrubber. The typical particle trajectories for the normal type cyclone are calculated. The optimum mist injection position is determined based on the simulation of particle trajectories. Two types of cyclone scrubbers that have different mist injection position were tested in this research. It was found that the particle separation efficiency is strongly depended on the mist injection position. With the injection of mist, the 50% cut size is smaller than the case with the injection of air only. It was also found that increasing liquid to gas flow ratio enhances the separation efficiency. The experimental data agreed with the numerical simulation based on the direct flow calculation method. (C) 2003 Elsevier B.V. All rights reserved.
引用
收藏
页码:221 / 230
页数:10
相关论文
共 8 条
[1]   PERFORMANCE-CHARACTERISTICS OF MULTICYCLONE AEROSOL SAMPLER [J].
BLACHMAN, MW ;
LIPPMANN, M .
AMERICAN INDUSTRIAL HYGIENE ASSOCIATION JOURNAL, 1974, 35 (06) :311-326
[2]   COLLECTION EFFICIENCY OF CYCLONE SEPARATORS [J].
DIETZ, PW .
AICHE JOURNAL, 1981, 27 (06) :888-892
[3]  
LIPPMANN M, 1979, STAUB REINHALT LUFT, V39, P7
[4]   EFFECT OF BLOW-DOWN ON FLUID-FLOW AND PARTICLE MOVEMENT IN CYCLONE CLASSIFIER [J].
YOSHIDA, H ;
FUJIOKA, T ;
HASHIMOTO, K ;
NAGAHASHI, K .
KAGAKU KOGAKU RONBUNSHU, 1995, 21 (03) :594-602
[5]   Elaborate classification of flyash particles by bench scale air cyclone [J].
Yoshida, H ;
Yamamoto, T ;
Okanishi, K ;
Morisaki, H ;
Nakamura, T ;
Iinoya, K .
KAGAKU KOGAKU RONBUNSHU, 1997, 23 (03) :363-370
[6]   Three-dimensional simulation of air cyclone and particle separation by a revised-type cyclone [J].
Yoshida, H .
COLLOIDS AND SURFACES A-PHYSICOCHEMICAL AND ENGINEERING ASPECTS, 1996, 109 :1-12
[7]   FINE-PARTICLE SEPARATION BY REVISED TYPE AIR-CYCLONE CLASSIFIER [J].
YOSHIDA, H ;
SAEKI, T ;
FUJIOKA, T ;
UEDA, T ;
FUYUKI, T .
KAGAKU KOGAKU RONBUNSHU, 1993, 19 (03) :476-482
[8]   SIZE CLASSIFICATION OF SUBMICRON POWDER BY AIR CYCLONE AND 3-DIMENSIONAL ANALYSIS [J].
YOSHIDA, H ;
SAEKI, T ;
HASHIMOTO, K ;
FUJIOKA, T .
JOURNAL OF CHEMICAL ENGINEERING OF JAPAN, 1991, 24 (05) :640-647