Study on Pinus Massonian Kraft Pulp Bleaching by Laccase/Xylanase System

被引：0
作者：
Wu, Shufang [1 ]
You, Jixue [1 ]
Lai, Qiuhua [1 ]
机构：
[1] Nanjing Forestry Univ, Jiangsu Prov Key Lab Pulp & Paper Sci & Technol, Nanjing 210037, Peoples R China
来源：
PROCEEDINGS OF INTERNATIONAL CONFERENCE ON PULPING, PAPERMAKING AND BIOTECHNOLOGY 2008: ICPPB '08, VOL 2 | 2008年
关键词：
laccase; laccase-mediator system; laccase-xylanase system; bleaching; Pinus massonia;
D O I：
暂无
中图分类号：
TB3 [工程材料学]; TS [轻工业、手工业、生活服务业];
学科分类号：
0805 ; 080502 ; 0822 ;
摘要：
LXS(laccase-xylanase system) was obtained after regulated cultivation on Flammulina velutipes. We used LXS in the pretreatment of pinus massonia kraft pulp, and then operated DED bleaching to this pulp as well as making a comparison of the result with the LMS (laccase-mediator system) pretreatment. The result showed that the conditions of the optimal process were as following: pH 4.2, pulp consistency 3%, temperature 40 degrees C; treatment time 3hr; enzyme dosage 10 IU.g(-1). Alkaline extraction was applied on the Pulp after LXS pretreatment, and the kappa number reduced 9.2% compared with the control pulp. In contrast, the kappa number of the pulp by LMS pretreatment reduced 8.3% compared with the control pulp. When DED bleaching was applied on the pulp after pretreatment, the brightness of the pulp by LXS pretreatment was 6.0% higher than that of the control pulp and was quite close to the brightness of the pulp by LMS pretreatment. Moreover, the strength of these two pulps was similar and it had no obvious decrease than that of the control pulp.
引用
收藏
页码：128 / 131
页数：4
相关论文
共 50 条
  • [21] STUDY OF COORDINATED PRETREATMENT OF XYLANASE AND LACCASE ON SODA-AQ WHEAT STRAW PULP BEFORE CEH BLEACHING
    Caixia Li Shanming Han Guigan Fang Shuchai Liu Research Institute of Chemical Processing and Utilization of Forest Products CAF Nanjing Shaanxi University of Science and Technology Xianyang
    天津科技大学学报, 2004, (S2) : 27 - 35
  • [22] Preliminary study on biobleaching of eucalyptus urophylla kraft pulp with laccase/mediator system
    Fu, Shiyu
    Zhan, Huaiyu
    Yu, Huisheng
    Chung-kuo Tsao Chih/China Pulp and Paper, 2000, 19 (02): : 8 - 12
  • [23] Study of ECF and TCF bleaching of birch kraft pulp
    Liu, Z
    Xu, LX
    Yang, SH
    EMERGING TECHNOLOGIES OF PULPING & PAPERMAKING OF FAST-GROWING WOOD, 1998, : 284 - 291
  • [24] Effect of xylanase pre- and post-treatment on oxygen bleaching of Oak kraft pulp
    Kim, DH
    Paik, KH
    JOURNAL OF INDUSTRIAL AND ENGINEERING CHEMISTRY, 2000, 6 (03) : 194 - 200
  • [25] IMPROVING ECF AND TCF BLEACHING OF OXYGEN- DELIGNIFIED KRAFT REED PULP WITH LACCASE TREATMENT
    Wang Ping
    Xie Chuanlong
    Zhong Linxin
    Yu Jichuan
    Fu Shiyu
    Zhan Huaiyu
    RESEARCH PROGRESS IN PAPER INDUSTRY AND BIOREFINERY (4TH ISETPP), VOLS 1-3, 2010, : 526 - 530
  • [26] Potential and limitation of Trametes versicolor laccase on biodegradation of Eucalyptus globulus and Pinus pinaster kraft pulp
    Oudia, Atika
    Queiroz, Joao
    Simoes, Rogerio
    ENZYME AND MICROBIAL TECHNOLOGY, 2008, 43 (02) : 144 - 148
  • [27] TOWARDS IMPROVEMENTS OF KRAFT PULP BLEACHING BY ADDITIONAL TREATMENTS
    Eugenio Martins, Maria E.
    Du, Xueyu
    Li, Jiebing
    16TH INTERNATIONAL SYMPOSIUM ON WOOD, FIBER AND PULPING CHEMISTRY, PROCEEDINGS, VOLS I & II, 2011, : 699 - 704
  • [28] Differential and synergistic effects of xylanase and laccase mediator system (LMS) in bleaching of soda and waste pulps
    Kapoor, M.
    Kapoor, R. K.
    Kuhad, R. C.
    JOURNAL OF APPLIED MICROBIOLOGY, 2007, 103 (02) : 305 - 317
  • [29] ECF bleaching of bamboo kraft pulp
    Vu, MTH
    Alén, R
    Pakkanen, H
    PAPERI JA PUU-PAPER AND TIMBER, 2006, 88 (02): : 106 - 114
  • [30] New polyoxometalate-laccase integrated system for kraft pulp delignification
    Gamelas, J. A. F.
    Pontes, A. S. N.
    Evtuguin, D. V.
    Xavier, A. M. R. B.
    Esculcas, A. P.
    BIOCHEMICAL ENGINEERING JOURNAL, 2007, 33 (02) : 141 - 147
12345