Rotor demagnetization effects on permanent magnet synchronous machines

被引：42

作者：

Ruschetti, Cristian ^{[1
]}

Verucchi, Carlos ^{[2
]}

Bossio, Guillermo ^{[1
]}

De Angelo, Cristian ^{[1
]}

Garcia, Guillermo ^{[1
]}

机构：

[1] Univ Nacl Rio Cuarto, Fac Ingn, Grp Elect Aplicada, Cordoba, Argentina

[2] Univ Nacl Ctr Prov Buenos Aires, Grp INTELYMEC, Buenos Aires, DF, Argentina

来源：

ENERGY CONVERSION AND MANAGEMENT | 2013年 / 74卷

关键词：

Permanent magnet synchronous machine; Demagnetization; Fault detection; Parallel windings; Finite element method; FAULT-DIAGNOSIS; DYNAMIC ECCENTRICITY; INDUCTION-MOTORS; LOAD; BARS;

D O I：

10.1016/j.enconman.2013.05.001

中图分类号：

O414.1 [热力学];

学科分类号：

摘要：

The effects of asymmetrical magnet faults on the rotor of Permanent Magnet Synchronous Machines (PMSM) are analyzed in the present work. Two different stator winding configurations, series and parallel connected windings, are considered in the analysis. From PMSM with parallel windings, a fault detection strategy based on the information contained in the branch-current spectrum is proposed. A fault severity factor is defined to quantify demagnetization on a single magnet. This factor is practically independent from the motor load conditions. Simulation results using a finite element model are obtained to evaluate the feasibility of the proposal. Additionally, voltage reduction and current derating due to rotor demagnetization are also evaluated. Experimental results are presented to validate the proposal. (C) 2013 Elsevier Ltd. All rights reserved.

引用

页码：1 / 8

页数：8

共 31 条

[1] A current monitoring system for diagnosing electrical failures in induction motors [J].

Acosta, GG ;

Verucchi, C ;

Gelso, ER .

MECHANICAL SYSTEMS AND SIGNAL PROCESSING, 2006, 20 (04) :953-965

[2] Condition monitoring and fault diagnosis in wind energy conversion systems: A review [J].

Amirat, Y. ;

Benbouzid, M. E. H. ;

Bensaker, B. ;

Wamkeue, R. .

IEEE IEMDC 2007: PROCEEDINGS OF THE INTERNATIONAL ELECTRIC MACHINES AND DRIVES CONFERENCE, VOLS 1 AND 2, 2007, :1434-+

[3] A new method for early fault detection and diagnosis of broken rotor bars [J].

Aydin, Ilhan ;

Karakose, Mehmet ;

Akin, Erhan .

ENERGY CONVERSION AND MANAGEMENT, 2011, 52 (04) :1790-1799

[4]

Batistela NJ, 2001, THESIS U FEDERAL SAN

[5] Advances in Diagnostic Techniques for Induction Machines [J].

Bellini, Alberto ;

Filippetti, Fiorenzo ;

Tassoni, Carta ;

Capolino, Gerard-Andre .

IEEE TRANSACTIONS ON INDUSTRIAL ELECTRONICS, 2008, 55 (12) :4109-4126

[6] Separating Broken Rotor Bars and Load Oscillations on IM Fault Diagnosis Through the Instantaneous Active and Reactive Currents [J].

Bossio, Guillermo R. ;

De Angelo, Cristian H. ;

Bossio, Jose M. ;

Pezzani, Carlos M. ;

Garcia, Guillermo O. .

IEEE TRANSACTIONS ON INDUSTRIAL ELECTRONICS, 2009, 56 (11) :4571-4580

[7]

Casadei Domenico, 2009, Proceedings of the 2009 IEEE International Symposium on Diagnostics for Electric Machines, Power Electronics and Drives. SDEMPED 2009, DOI 10.1109/DEMPED.2009.5292770

[8] Effect of rotor eccentricity on electric parameters in a PM brushless motor with parallel winding connections [J].

Chen, H. S. ;

Tsai, M. C. .

JOURNAL OF APPLIED PHYSICS, 2009, 105 (07)

[9] Fault analysis of a PM brushless DC motor using finite element method [J].

Dai, M ;

Keyhani, A ;

Sebastian, T .

IEEE TRANSACTIONS ON ENERGY CONVERSION, 2005, 20 (01) :1-6

[10] Analysis of voltage unbalance effects on induction motors with open and closed slots [J].

Donolo, Pablo ;

Bossio, Guillermo ;

De Angelo, Cristian .

ENERGY CONVERSION AND MANAGEMENT, 2011, 52 (05) :2024-2030

← 1 2 3 4 →