Effects of RF Magnetron Sputtering Deposition Power on Crystallinity and Thermoelectric Properties of Antimony Telluride and Bismuth Telluride Thin Films on Flexible Substrates

被引:13
作者
Amirghasemi, Farbod [1 ,2 ]
Kassegne, Sam [1 ,2 ]
机构
[1] San Diego State Univ, Dept Mech Engn, Coll Engn, NanoFAB SDSU Res Lab, 5500 Campanile Dr, San Diego, CA 92182 USA
[2] Bill & Melinda Gates Ctr Comp Sci & Engn, Ctr Neurotechnol CNT, 3800 E Stevens Way NE,Box 37, Seattle, WA 98195 USA
基金
美国国家科学基金会;
关键词
Thin film; RF sputtering; sputtering power; thermoelectric;
D O I
10.1007/s11664-020-08681-y
中图分类号
TM [电工技术]; TN [电子技术、通信技术];
学科分类号
0808 ; 0809 ;
摘要
Thermoelectric materials carry significant promise for self-powering future generations of unattended microdevices and wearable devices. The current increased interest in such devices highlights the need for research to provide understanding of the basic material properties of thermoelectric materials, specifically in thin-film form, deposited on flexible polymer substrates. In this study, the surface topography, crystalline structure, and electrical properties of sputtered thin films of two of the most common thermoelectric materials, i.e., antimony telluride (Sb2Te3) and bismuth telluride (Bi2Te3), supported on silicon and polymer substrates were investigated. The study focuses on determining the effect of the sputtering power and underlying substrate on the crystal structure formation as well as grain size of the resulting thin film. Radiofrequency (RF) magnetron sputtering with power levels from 50 W to 200 W was used to deposit these layers on several test structures. The results demonstrate that increasing the RF sputtering power resulted in (i) an increase in the crystalline size (from 0.48 nm to 29.66 nm for Sb2Te3 and from 10.60 nm to 20.29 nm for Bi2Te3), (ii) a significant increase in the content of tellurium (Te) in the Sb2Te3 and Bi2Te3 thin films, (iii) an order-of-magnitude increase in the electrical conductivity of the Bi2Te3 thin film fabricated on silicon wafer, and (iv) a 150% increase in the Seebeck coefficient for both Bi2Te3 and Sb2Te3 samples. Furthermore, surface roughness analysis showed that deposition on polyimide substrate modestly increased the surface roughness (R-a), from 6.59 nm to 9.91 nm for Bi2Te3 and from 12.46 nm to 15.41 nm for Sb2Te3. The electrical resistivity of Bi2Te3 thin films on polyimide was found to be 2.72 x 10(-3) omega m, compared with 1.58 x 10(-3) omega m on silicon substrate, while for Sb2Te3,, the electrical resistivity on polyimide substrate increased to 580 x 10(-3) omega m as compared with 145 x 10(-3) omega m on silicon substrate. Taken together, the results of this work demonstrate that the use of high deposition power during RF sputtering of Sb2Te3 and Bi2Te3 thin films results in significant improvements in their crystallinity, conductivity, and Seebeck coefficient, which are key material properties of great importance for thermoelectric materials.
引用
收藏
页码:2190 / 2198
页数:9
相关论文
共 35 条
[21]  
Lin J.-M., 2015, Journal of Nanomaterials, V16, P225
[22]   Annealing Effect on the Thermoelectric Properties of Bi2Te3 Thin Films Prepared by Thermal Evaporation Method [J].
Lin, Jyun-Min ;
Chen, Ying-Chung ;
Lin, Chi-Pi .
JOURNAL OF NANOMATERIALS, 2013, 2013
[23]   Ultra-Capacitive Carbon Neural Probe Allows Simultaneous Long-Term Electrical Stimulations and High-Resolution Neurotransmitter Detection [J].
Nimbalkar, Surabhi ;
Castagnola, Elisa ;
Balasubramani, Arvind ;
Scarpellini, Alice ;
Samejima, Soshi ;
Khorasani, Abed ;
Boissenin, Adrien ;
Thongpang, Sanitta ;
Moritz, Chet ;
Kassegne, Sam .
SCIENTIFIC REPORTS, 2018, 8
[24]   [Bi]:[Te] Control, Structural and Thermoelectric Properties of Flexible BiXTey Thin Films Prepared by RF Magnetron Sputtering at Different Sputtering Pressures [J].
Nuthongkum, Pilaipon ;
Sakdanuphab, Rachsak ;
Horprathum, Mati ;
Sakulkalavek, Aparporn .
JOURNAL OF ELECTRONIC MATERIALS, 2017, 46 (11) :6444-6450
[25]   Thermoelectrics: a review of present and potential applications [J].
Riffat, SB ;
Ma, XL .
APPLIED THERMAL ENGINEERING, 2003, 23 (08) :913-935
[26]   Adhesive RFID Sensor Patch for Monitoring of Sweat Electrolytes [J].
Rose, Daniel P. ;
Ratterman, Michael E. ;
Griffin, Daniel K. ;
Hou, Linlin ;
Kelley-Loughnane, Nancy ;
Naik, Rajesh R. ;
Hagen, Joshua A. ;
Papautsky, Ian ;
Heikenfeld, Jason C. .
IEEE TRANSACTIONS ON BIOMEDICAL ENGINEERING, 2015, 62 (06) :1457-1465
[27]   Thermoelectrics, an environmentally-friendly source of electrical power [J].
Rowe, DM .
RENEWABLE ENERGY, 1999, 16 (1-4) :1251-1256
[28]   Raman spectroscopy of Bi-Te thin films [J].
Russo, V. ;
Bailini, A. ;
Zamboni, M. ;
Passoni, M. ;
Conti, C. ;
Casari, C. S. ;
Bassi, A. Li ;
Bottani, C. E. .
JOURNAL OF RAMAN SPECTROSCOPY, 2008, 39 (02) :205-210
[29]   Design and production of a novel microfluidic device for the capture and isolation of circulating tumor cell clusters [J].
Shaner, Sebastian W. ;
Allen, Jeffrey K. ;
Felderman, Martina ;
Pasko, Evan T. ;
Wimer, Carina D. ;
Cosford, Nicholas D. P. ;
Kassegne, Samuel ;
Teriete, Peter .
AIP ADVANCES, 2019, 9 (06)
[30]   Enhancing thermoelectric properties of Sb2Te3 flexible thin film through microstructure control and crystal preferential orientation engineering [J].
Shen, Shengfei ;
Zhu, Wei ;
Deng, Yuan ;
Zhao, Huaizhou ;
Peng, Yuncheng ;
Wang, Chuanjun .
APPLIED SURFACE SCIENCE, 2017, 414 :197-204