Control of the Power in Induction Heating Systems with L-LC Resonant Voltage Source Inverters

被引：0

作者：

Popescu, Mihaela ^{[1
]}

Bitoleanu, Alexandru ^{[1
]}

Suru, Vlad ^{[1
]}

机构：

[1] Univ Craiova, Fac Elect Engn, Craiova, Romania

来源：

2013 4TH INTERNATIONAL SYMPOSIUM ON ELECTRICAL AND ELECTRONICS ENGINEERING (ISEEE) | 2013年

关键词：

converter control; induction heating; resonant converter; voltage source inverters; DESIGN;

D O I：

暂无

中图分类号：

TM [电工技术]; TN [电子技术、通信技术];

学科分类号：

0808 ; 0809 ;

摘要：

This paper is a synthesis of the control circuit in an induction heating system with three-phase fully-controlled rectifier, single-phase voltage source inverter and L-LC resonant load. The attention is mainly directed on the control of the power transmitted to the induction coil. It is highlighted that the analytical design of a proportional integral derivative or proportional integral controller is practically impossible when the direct control of the current through inductor is desired. The two possibilities of power control taken into consideration are the inverter output current control and the inverter input voltage control. The design of the current and voltage controllers of proportional integral derivative type was carried out successfully based on Modulus Optimum criterion in Kessler variant. The performances of the control system in both variants of the power control were tested and validated by simulation under the Matlab-Simulink environment by using real parameters of induction coils and heated pipes from a leading Romanian manufacturer.

引用

页数：6

共 50 条

[11] Active Damping of Power Control for Grid-Forming Inverters in LC Resonant Grids [J].

Liu, Shiyi ;

Wu, Heng ;

Wang, Xiongfei .

2022 IEEE ENERGY CONVERSION CONGRESS AND EXPOSITION (ECCE), 2022,

[12] Short-Circuit Critical Frequency for Induction Heating Parallel Resonant Inverters [J].

Jordan, J. ;

Magraner, J. M. ;

Cases, C. ;

Esteve, V. ;

Dede, E. ;

Sanchis, E. ;

Maset, E. ;

Ferreres, A. ;

Ejea, J. B. ;

Gumbau, Eva .

EPE: 2009 13TH EUROPEAN CONFERENCE ON POWER ELECTRONICS AND APPLICATIONS, VOLS 1-9, 2009, :3407-+

[13] Reduced-Order Models of Series Resonant Inverters in Induction Heating Applications [J].

Dominguez, Alberto ;

Angel Barragan, Luis ;

Ignacio Artigas, Jose ;

Otin, Aranzazu ;

Urriza, Isidro ;

Navarro, Denis .

IEEE TRANSACTIONS ON POWER ELECTRONICS, 2017, 32 (03) :2300-2311

[14] Several Configurations and Resonant Control for Multiphase Induction Heating Systems [J].

Quoc Dung Phan ;

Anh Tuan Vo ;

Thang Pham Ngoc ;

Maussion, Pascal .

2016 52ND ANNUAL MEETING OF THE IEEE INDUSTRY APPLICATIONS SOCIETY (IAS), 2016,

[15] Resonant control of multi-phase induction heating systems [J].

Nguyen Kien Long ;

Caux, Stephane ;

Kestelyn, Xavier ;

Pateau, Olivier ;

Maussion, Pascal .

38TH ANNUAL CONFERENCE ON IEEE INDUSTRIAL ELECTRONICS SOCIETY (IECON 2012), 2012, :3293-3298

[16] Grid Voltage Modulated Direct Power Control for Grid Connected Voltage Source Inverters [J].

Gui, Yonghao ;

Kim, Chunghun ;

Chung, Chung Choo .

2017 AMERICAN CONTROL CONFERENCE (ACC), 2017, :2078-2084

[17] Simplified model of resonant inverters for the modelisation of induction heating of billet [J].

Paya, Bernard .

IECON 2014 - 40TH ANNUAL CONFERENCE OF THE IEEE INDUSTRIAL ELECTRONICS SOCIETY, 2014, :3270-3276

[18] Maximizing Power Transfer in Induction Heating System with Voltage Source Inverter [J].

Bitoleanu, Alexandru ;

Popescu, Mihaela ;

Suru, Vlad .

NONLINEAR DYNAMICS OF ELECTRONIC SYSTEMS, 2014, 438 :134-141

[19] Model Predictive Control for Resonant Power Converters Applied to Induction Heating [J].

Lucia, Sergio ;

Navarro, Denis ;

Samago, Hector ;

Lucia, Oscar .

2018 IEEE 27TH INTERNATIONAL SYMPOSIUM ON INDUSTRIAL ELECTRONICS (ISIE), 2018, :246-251

[20] Optimizing the Efficiency of Series Resonant Half-Bridge Inverters for Induction Heating Applications [J].

Esteve, Vicente ;

Jordan, Jose ;

Bellido, Juan L. .

ELECTRONICS, 2025, 14 (06)

← 1 2 3 4 5 →