Modelling the kinetics of strain induced precipitation in Nb microalloyed steels

被引：394
作者：
Dutta, B [1 ]
Palmiere, EJ [1 ]
Sellars, CM [1 ]
机构：
[1] Univ Sheffield, Dept Mat Engn, Sheffield S1 3JD, S Yorkshire, England
来源：
ACTA MATERIALIA | 2001年 / 49卷 / 05期
关键词：
diffusion; steels; theory & modelling; kinetics; thermomechanical processing;
D O I：
10.1016/S1359-6454(00)00389-X
中图分类号：
T [工业技术];
学科分类号：
08 ;
摘要：
Strain induced precipitation is a key phenomenon that controls the microstructure evolution during the finish rolling stages of microalloyed steels. Extensive research has shown that the precipitation of Nb(CN) delays the onset of recrystallisation. This paper presents a model to describe the precipitation kinetics during isothermal holding following high temperature deformation in Nb-containing steels. The model is based on the assumption that heterogeneous nucleation of precipitates on dislocations and enhanced coarsening due to pipe diffusion are responsible behind the accelerated kinetics observed in strain induced precipitation. Results show a very good agreement between reported experimental observations and predictions of the present model for precipitate size and volume fraction evolution. (C) 2001 Acta Materialia Inc. Published by Elsevier Science Ltd. All rights reserved.
引用
收藏
页码：785 / 794
页数：10
相关论文
共 25 条
[1]   COMPARISON OF RELATIVE INTERFACIAL ENERGIES OF DISORDERED INTERPHASE (ALPHA-THETA) AND GRAIN (ALPHA-ALPHA) BOUNDARIES AT GRAIN BOUNDARY PRECIPITATES IN AL-4 PERCENT CU DURING GROWTH AND AT EQUILIBRIUM [J].
AARON, HB ;
AARONSON, HI .
ACTA METALLURGICA, 1970, 18 (06) :699-&
[2]  
Akamatsu S, 1990, P INT S MATH MOD HOT, P467
[3]   DYNAMIC PRECIPITATION AND SOLUTE HARDENING IN A V-MICROALLOYED STEEL AND 2 NB STEELS CONTAINING HIGH-LEVELS OF MN [J].
AKBEN, MG ;
WEISS, I ;
JONAS, JJ .
ACTA METALLURGICA, 1981, 29 (01) :111-121
[4]   NUCLEATION ON DISLOCATIONS [J].
CAHN, JW .
ACTA METALLURGICA, 1957, 5 (03) :169-172
[5]  
DEARDO AJ, 1981, P ITS NIOB SAN FRANC, P585
[6]   Influence of predeformation and ageing of an Al-Zn-Mg alloy - II. Modeling of precipitation kinetics and yield stress [J].
Deschamps, A ;
Brechet, Y .
ACTA MATERIALIA, 1998, 47 (01) :293-305
[7]  
DUTTA B, 1987, MATER SCI TECH SER, V3, P197, DOI 10.1179/026708387790122846
[8]   MECHANISM AND KINETICS OF STRAIN INDUCED PRECIPITATION OF NB(C, N) IN AUSTENITE [J].
DUTTA, B ;
VALDES, E ;
SELLARS, CM .
ACTA METALLURGICA ET MATERIALIA, 1992, 40 (04) :653-662
[9]  
DUTTA B, 1996, THESIS INDIAN I SCI
[10]   INFLUENCE OF DISLOCATION DENSITY AND DISTRIBUTION ON THE AGING BEHAVIOR OF 6061 AL-SICW COMPOSITES [J].
DUTTA, I ;
BOURELL, DL .
ACTA METALLURGICA ET MATERIALIA, 1990, 38 (11) :2041-2049
123