A novel tin oxide-based recoverable thick film SO2 gas sensor promoted with magnesium and vanadium oxides

被引：92

作者：

Lee, Soo Chool ^{[1
]}

Hwang, Byung Wook ^{[1
]}

Lee, Soo Jae ^{[2
]}

Choi, Ho Yun ^{[1
]}

Kim, Seong Yeol ^{[1
]}

Jung, Suk Yong ^{[1
]}

Ragupathy, Dhanusuraman ^{[1
]}

Lee, Duk Dong ^{[3
]}

Kim, Jae Chang ^{[1
]}

机构：

[1] Kyungpook Natl Univ, Dept Chem Engn, Taegu 702701, South Korea

[2] GS Caltex Co, Fuel Cell R&D Ctr, Seoul 134848, South Korea

[3] Kyungpook Natl Univ, Sch Elect Engn & Comp Sci, Taegu 702701, South Korea

来源：

SENSORS AND ACTUATORS B-CHEMICAL | 2011年 / 160卷 / 01期

关键词：

Sensor; Tin oxide; Sulfur dioxide; MgO; V2O5; CHEMICAL WARFARE AGENTS; SENSING BEHAVIOR; METAL-OXIDES; IRON-OXIDE; DIOXIDE; REMOVAL; REGENERATION; SENSITIVITY;

D O I：

10.1016/j.snb.2011.09.070

中图分类号：

O65 [分析化学];

学科分类号：

070302 ; 081704 ;

摘要：

An SnO2-based thick film gas sensor was developed to detect sulfur dioxide (SO2) gas at the ppm level. The SnO2-based sensors were prepared by mixing tin oxide with various promoters such as V2O5, MoO3, Sb2O3, Al2O3, CeO2, and MgO. Their sensor responses and recovery behaviors were investigated in a flow system. It was found that the SnO2-based gas sensor promoted by simultaneous mixing of both 5 wt% MgO and 2 wt% V2O5, showed not only a 44% sensor response for the detection of SO2 at the 1 ppm level, but also good repeatability by means of thermal treatment in air. In particular, this sensor showed a response of approximately 20% even at the level of 0.1 ppm (100 ppb). The sensor recovery properties, as well as the sensor response, could be enhanced by the simultaneous addition of both MgO and V2O5 promoters as compared with the SnO2 sensor. These results are due to the promoting effects of MgO and V2O5 on response and recovery properties of the SnO2-based sensor, respectively. (C) 2011 Elsevier B.V. All rights reserved.

引用

页码：1328 / 1334

页数：7

共 21 条

[1] Detection of DEMP vapors using SnO2-based gas sensors:: understanding of the chemical reactional mechanism
Berger, F
Brunol, E
Planade, R
Chambaudet, A
[J]. THIN SOLID FILMS, 2003, 436 (01) : 1 - 8
[2] Tin dioxide-based gas sensors for SO2 detection:: a chemical interpretation of the increase in sensitivity obtained after a primary detection
Berger, F
Fromm, M
Chambaudet, A
Planade, R
[J]. SENSORS AND ACTUATORS B-CHEMICAL, 1997, 45 (03) : 175 - 181
[3] An XPS and FTIR study of SO2 adsorption on SnO2 surfaces
Berger, F
Beche, E
Berjoan, R
Klein, D
Chambaudet, A
[J]. APPLIED SURFACE SCIENCE, 1996, 93 (01) : 9 - 16
[4] Classification of chemical warfare agents using thick film gas sensor array
Choi, NJ
Kwak, JH
Lim, YT
Bahn, TH
Yun, KY
Kim, JC
Huh, JS
Lee, DD
[J]. SENSORS AND ACTUATORS B-CHEMICAL, 2005, 108 (1-2) : 298 - 304
[5] Vanadium doped tin dioxide as a novel sulfur dioxide sensor
Das, S.
Chakraborty, S.
Parkash, O.
Kumar, D.
Bandyopadhyay, S.
Samudrala, S. K.
Sen, A.
Maiti, H. S.
[J]. TALANTA, 2008, 75 (02) : 385 - 389
[6] A review of electrolyte and electrode materials for high temperature electrochemical CO2 and SO2 gas sensors
Fergus, Jeffrey W.
[J]. SENSORS AND ACTUATORS B-CHEMICAL, 2008, 134 (02) : 1034 - 1041
[7] Modelling of SO2 detection by tin dioxide gas sensors
Girardin, D
Berger, F
Chambaudet, A
Planade, R
[J]. SENSORS AND ACTUATORS B-CHEMICAL, 1997, 43 (1-3) : 147 - 153
[8] Regenerable MgO-Based SOx removal sorbents promoted with cerium and iron oxide in RFCC
Jae, LS
Jun, HK
Jung, SY
Lee, TJ
Ryu, CK
Kim, JC
[J]. INDUSTRIAL & ENGINEERING CHEMISTRY RESEARCH, 2005, 44 (26) : 9973 - 9978
[9] Tin oxide-based methane gas sensor promoted by alumina-supported Pd catalyst
Kim, JC
Jun, HK
Huh, JS
Lee, DD
[J]. SENSORS AND ACTUATORS B-CHEMICAL, 1997, 45 (03) : 271 - 277
[10] Effects of Textural Properties on the Response of a SnO2-Based Gas Sensor for the Detection of Chemical Warfare Agents
Lee, Soo Chool
Kim, Seong Yeol
Lee, Woo Suk
Jung, Suk Yong
Hwang, Byung Wook
Ragupathy, Dhanusuraman
Lee, Duk Dong
Lee, Sang Yeon
Kim, Jae Chang
[J]. SENSORS, 2011, 11 (07): : 6893 - 6904

← 1 2 3 →