Filtered sub-grid constitutive models for fluidized gas-particle flows constructed from 3-D simulations

被引：129

作者：

Sarkar, Avik ^{[1
,2
]}

Milioli, Fernando E. ^{[3
]}

Ozarkar, Shailesh ^{[4
]}

Li, Tingwen ^{[5
,6
]}

Sun, Xin ^{[1
]}

Sundaresan, Sankaran ^{[3
]}

机构：

[1] Pacific Northwest Natl Lab, Fundamental & Computat Sci Directorate, POB 999,MSIN K7-90, Richland, WA 99352 USA

[2] Pfizer Inc, Worldwide Res & Dev, MS 8156-014,Eastern Point Rd, Groton, CT 06340 USA

[3] Princeton Univ, Chem & Biol Engn, A-315 Engn Quadrangle, Princeton, NJ 08544 USA

[4] ANSYS Inc, Canonsburg, PA 15317 USA

[5] Natl Energy Technol Lab, 3610 Collins Ferry Rd, Morgantown, WV 26507 USA

[6] AECOM, 3610 Collins Ferry Rd, Morgantown, WV 26507 USA

来源：

CHEMICAL ENGINEERING SCIENCE | 2016年 / 152卷

关键词：

Computational fluid dynamics (CFD); Constitutive models; Fluidization; Multiphase flow; Scale-up; Two-fluid model; TRAVELING-WAVE SOLUTIONS; 2-FLUID MODELS; DRAG MODELS; VALIDATION; DIFFUSION; EQUATIONS;

D O I：

10.1016/j.ces.2016.06.023

中图分类号：

TQ [化学工业];

学科分类号：

0817 ;

摘要：

The accuracy of fluidized-bed CFD predictions using the two-fluid model can be improved significantly, even when using coarse grids, by replacing the microscopic kinetic-theory-based closures with coarse grained constitutive models. These coarse-grained constitutive relationships, called filtered models, account for the unresolved gas-particle structures (clusters and bubbles) via sub-grid corrections. Following the previous 2-D approaches of Igci et al. [AIChE J., 54(6), 1431-1448, 2008] and Milioli et al. [AIChE J., 59(9), 3265-3275, 2013], new closures for the filtered inter-phase drag and stresses in the gas and particle phases are constructed from highly-resolved 3-D simulations of gas-particle flows. These new closure relations are then validated through the bubbling-fluidized-bed challenge problem presented by National Energy Technology Laboratory and Particulate Solids Research Inc. (C) 2016 Elsevier Ltd. All rights reserved.

引用

页码：443 / 456

页数：14

共 27 条

[21] A dynamic multiphase turbulence model for coarse-grid simulations of fluidized gas-particle suspensions
Rauchenzauner, Stefanie
Schneiderbauer, Simon
CHEMICAL ENGINEERING SCIENCE, 2022, 247
[22] Assessment of gas-particle flow models for pseudo-2D fluidized bed applications
Venier, Cesar M.
Marquez Damian, Santiago
Nigro, Norberto M.
CHEMICAL ENGINEERING COMMUNICATIONS, 2018, 205 (04) : 456 - 478
[23] Simulation of 3-D gas-particle flows and coal combustion in a tangentially fired furnace using a two-fluid-trajectory model
Zhou, LX
Li, L
Li, RX
Zhang, J
POWDER TECHNOLOGY, 2002, 125 (2-3) : 226 - 233
[24] Consistent closures for Euler-Lagrange models of bi-disperse gas-particle suspensions derived from particle-resolved direct numerical simulations
Municchi, Federico
Radl, Stefan
INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2017, 111 : 171 - 190
[25] 3D CFD-PBM simulation of gas-solid bubbling beds of Geldart A particles with sub-grid drag correction
Hu, Shanwei
Liu, Xinhua
CHEMICAL ENGINEERING SCIENCE, 2023, 275
[26] Dense gas-particle suspension upward flow used as heat transfer fluid in solar receiver: PEPT experiments and 3D numerical simulations
Ansart, Renaud
Garcia-Trinanes, Pablo
Boissiere, Benjamin
Benoit, Hadrien
Seville, Jonathan P. K.
Simonin, Olivier
POWDER TECHNOLOGY, 2017, 307 : 25 - 36
[27] Analysis of the time-averaged gas-solid drag force based on data from transient 3D CFD simulations of fluidized beds
Kallio, Sirpa
Peltola, Juho
Niemi, Timo
POWDER TECHNOLOGY, 2015, 274 : 227 - 238

← 1 2 3 →