Formation mechanism of titanium boride nanoparticles by RF induction thermal plasma

被引：47

作者：

Cheng, Yingying ^{[1
]}

Shigeta, Masaya ^{[2
]}

Choi, Sooseok ^{[1
]}

Watanabe, Takayuki ^{[1
]}

机构：

[1] Tokyo Inst Technol, Dept Environm Chem & Engn, Yokohama, Kanagawa 227, Japan

[2] Tohoku Univ, Dept Mech Syst & Design, Sendai, Miyagi 980, Japan

来源：

CHEMICAL ENGINEERING JOURNAL | 2012年 / 183卷

关键词：

RF induction thermal plasma; Titanium boride; Nanoparticle synthesis; Experiment; Numerical analysis; NUCLEATION; CONDENSATION; EVAPORATION; PARTICLES; REACTOR; MODELS; GROWTH;

D O I：

10.1016/j.cej.2011.12.040

中图分类号：

X [环境科学、安全科学];

学科分类号：

08 ; 0830 ;

摘要：

The formation mechanism of titanium boride functional nanoparticles by the radio frequency induction thermal plasma was investigated by experiment and numerical analysis. The mixed powders of titanium and boron were injected into the plasma and evaporated immediately, and then nanoparticles were produced through the quenching process. The nanoparticle products were characterized by phase composition and crystalline diameter. TiB2 was easily synthesized with a low powder feed rate in the boron-rich condition, because the molar ratio of evaporated and nucleated boron in plasma was enhanced. The prepared titanium boride nanoparticles had the average crystalline diameter ranging from 10 to 30 nm, and it was reduced with decreasing the powder feed rate and titanium content in the raw material due to abundant number of boron nuclei. This paper demonstrates the feasibility of the control of titanium boride nanoparticles' crystalline mean diameter and phase composition with different raw material condition in the RF induction thermal plasma synthesis. (C) 2011 Elsevier B.V. All rights reserved.

引用

页码：483 / 491

页数：9

共 30 条

[1] Angelino G., 1991, MODERN RES TOPICS AE, P59
[2] [Anonymous], 2020, Gothenburg Protocol to reduce transboundary air pollution, DOI DOI 10.5860/CHOICE.44-4512
[3] Synthesis of Titanium Boride Nanoparticles by Induction Thermal Plasmas
Cheng, Yingying
Watanabe, Takayuki
[J]. JOURNAL OF CHEMICAL ENGINEERING OF JAPAN, 2011, 44 (08) : 583 - 589
[4] Modelling of the reactive synthesis of ultra-fine powders in a thermal plasma reactor
Desilets, M
Bilodeau, JF
Proulx, P
[J]. JOURNAL OF PHYSICS D-APPLIED PHYSICS, 1997, 30 (13) : 1951 - 1960
[5] TIME-DEPENDENT AEROSOL MODELS AND HOMOGENEOUS NUCLEATION RATES
GIRSHICK, SL
CHIU, CP
MCMURRY, PH
[J]. AEROSOL SCIENCE AND TECHNOLOGY, 1990, 13 (04) : 465 - 477
[6] Production of Nanoparticles in Thermal Plasmas: A Model Including Evaporation, Nucleation, Condensation, and Fractal Aggregation
Gonzalez, Norma Yadira Mendoza
El Morsli, Mbark
Proulx, Pierre
[J]. JOURNAL OF THERMAL SPRAY TECHNOLOGY, 2008, 17 (04) : 533 - 550
[7] Synthesis of functional TiO2-based nanoparticles in radio frequency induction thermal plasma
Ishigaki, Takamasa
Li, Ji-Guang
[J]. PURE AND APPLIED CHEMISTRY, 2008, 80 (09) : 1971 - 1979
[8] Japan Institute of Metals, 1993, MET DAT BOOK
[9] MODELING THE STRUCTURE OF LIQUID BORON
KHANTADZE, DV
TOPURIDZE, NJ
[J]. JOURNAL OF THE LESS-COMMON METALS, 1986, 117 (1-2): : 105 - 107
[10] STRUCTURE, DEFECTS AND PROPERTIES OF SOME REFRACTORY BORIDES
LUNDSTROM, T
[J]. PURE AND APPLIED CHEMISTRY, 1985, 57 (10) : 1383 - 1390

← 1 2 3 →