Variation of age-hardening behavior of TM-addition Al-Mg-Si alloys

被引：11
作者：
Wang, Shumei [2 ]
Matsuda, Kenji [1 ]
Kawabata, Tokimasa [1 ]
Yamazaki, Toshinari [1 ]
Ikeno, Susumu [1 ]
机构：
[1] Toyama Univ, Grad Sch Sci & Engn Res, Toyama 930, Japan
[2] Toyama Univ, Grad Sch Sci & Engn Educ, Toyama 930, Japan
来源：
JOURNAL OF ALLOYS AND COMPOUNDS | 2011年 / 509卷 / 41期
关键词：
Transition metals; Al-Mg-Si alloy; Age hardening; Transmission electron microscopy; Dispersoid; Precipitate; CRYSTAL-STRUCTURE; ALUMINUM-ALLOYS; PHASE;
D O I：
10.1016/j.jallcom.2011.07.067
中图分类号：
O64 [物理化学（理论化学）、化学物理学];
学科分类号：
070304 ; 081704 ;
摘要：
Microstructure and aging hardness variation of Al-Mg-Si-TM alloys (TM = Co, Ni, Cr, Mn and Fe) were investigated to reveal the effect of transition metals (TMs) on the age hardening behavior of Al-Mg-Si alloy using transmission electron microscopy. The peak hardness of Co-or Ni-addition alloys is higher than the base alloy; Fe-or Cr-addition alloys is similar to the base alloy but Mn-addition alloy is lower than the base alloy. It was found different TM formed the dispersoids with different amounts of Si, which results in the different densities of the precipitates in different alloys. Si is expensed to form the dispersoid of Al(TM) Si for Cr-, Mn-and Fe-addition alloys. The ratio of TM: Si calculated from the EDS result of the dispersoid is the largest for Fe-and smallest for Mn-addition alloys. On the other hand, Si is not expensed to form such dispersoid in Co-and Ni-addition alloys. It is thought that this will result in the difference of Si in the matrix for the formation of the precipitate. (C) 2011 Elsevier B.V. All rights reserved.
引用
收藏
页码：9876 / 9883
页数：8
相关论文
共 50 条
  • [41] The effect of Zn on precipitation in Al-Mg-Si alloys
    Saito, Takeshi
    Wenner, Sigurd
    Osmundsen, Elisa
    Marioara, Calin D.
    Andersen, Sigmund J.
    Royset, Jostein
    Lefebvre, Williams
    Holmestad, Randi
    PHILOSOPHICAL MAGAZINE, 2014, 94 (21) : 2410 - 2425
  • [42] Effects of Zn addition on the age hardening behavior and precipitation evolution of an Al-Mg-Si-Cu alloy
    Zhu, Shang
    Li, Zhihui
    Yan, Lizhen
    Li, Xiwu
    Huang, Shuhui
    Yan, Hongwei
    Zhang, Yongan
    Xiong, Baiqing
    MATERIALS CHARACTERIZATION, 2018, 145 : 258 - 267
  • [43] A simple hardening rule accounting for time-dependent behavior in Al-Mg-Si alloys
    Correia, J. P. M.
    Simoes, F.
    Gracio, J. J.
    Barlat, F.
    Ahzi, S.
    MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2007, 456 (1-2): : 170 - 179
  • [44] Effect of Sc addition on the microstructures and age-hardening behavior of an Al-Cu-Mg-Ag alloy
    Bai, Song
    Yi, Xinlei
    Liu, Guanhua
    Liu, Zhiyi
    Wang, Jian
    Zhao, Juangang
    MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2019, 756 : 258 - 267
  • [45] The effect of Zn on the age hardening response in an Al-Mg-Si alloy
    Ding, X. P.
    Cui, H.
    Zhang, J. X.
    Li, H. X.
    Guo, M. X.
    Lin, Z.
    Zhuang, L. Z.
    Zhang, J. S.
    MATERIALS & DESIGN, 2015, 65 : 1229 - 1235
  • [46] Improved age-hardening behavior of Mg-Sn-Mn alloy by addition of Ag and Zn
    Huang, X. -F.
    Zhang, W. -Z.
    MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2012, 552 : 211 - 221
  • [47] Age-hardening behavior of cast Al-Si base alloy
    Li, RX
    Li, RD
    Zhao, YH
    He, LZ
    Li, CX
    Guan, HR
    Hu, ZQ
    MATERIALS LETTERS, 2004, 58 (15) : 2096 - 2101
  • [48] The effects of Ti on the precipitation evolution and age-hardening behavior of Al-7Si-Mg alloy
    Wang, Yifan
    Lu, Yanli
    Xu, Jinhan
    Zhang, Shiyao
    Wu, Wei
    Chen, Zheng
    INTERMETALLICS, 2022, 148
  • [49] Investigation on the age-hardening behavior of Al-Si-Cu-Mg cast alloys by mechanical testing, microstructural characterization, and a CNGT based precipitation model
    Mao, Fengxin
    Weidt, Moritz
    Staron, Peter
    Busch, Sebastian
    Stark, Andreas
    Barrales-Mora, Luis
    INTERNATIONAL JOURNAL OF MATERIALS RESEARCH, 2023, 114 (01) : 53 - 64
  • [50] The effect of alloying elements on the ductility of Al-Mg-Si alloys
    Remoe, Magnus S.
    Marthinsen, Knut
    Westermann, Ida
    Pedersen, Ketill
    Royset, Jostein
    Marioara, Calin
    MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2017, 693 : 60 - 72
12345