Investigation of the parameters affecting the morphology of zinc oxide (ZnO) nanoparticles synthesized by precipitation method

被引:12
|
作者
Rezaei, A. [1 ]
Katoueizadeh, E. [1 ]
Zebarjad, S. M. [1 ]
机构
[1] Shiraz Univ, Engn Fac, Dept Mat Sci & Engn, Shiraz, Iran
关键词
Nanoparticles; Zinc oxide; Precipitation method; Synthesis parameters; Morphology; AQUEOUS-SOLUTIONS; TEMPERATURE; NANOSTRUCTURES; PARTICLES; HYDROXIDE; NANOBELTS; FILMS;
D O I
10.1016/j.mtchem.2022.101239
中图分类号
O6 [化学];
学科分类号
0703 ;
摘要
In this work, zinc oxide (ZnO) nanoparticles were synthesized using aqueous solutions of ZnSO4 and NaOH at ambient temperature and 70 degrees C. The nanoparticles synthesized at these two temperatures were identified and analyzed by scanning electron microscopy (SEM), X-ray diffraction (XRD), infrared spec-troscopy (FTIR), dynamic light scattering (DLS), and zeta potential (ZP). SEM micrographs showed that temperature, method of mixing, and stoichiometric ratio could significantly affect the formation of particles of different sizes and morphology. Phase analysis of synthesized particles was performed by X-ray diffraction. The result showed that temperature had the tremendous potential to convert precursors into products to form a single-phase compound completely. These results were confirmed by the observed characteristic peaks in FTIR. The crystallite size was calculated using Scherer's equation and Rietveld analysis to investigate the effect of the calcination process on the crystal size of the synthesized particles. The results showed that the calcination process could significantly affect the crystal size of the synthesized particles. Both methods showed an increase in the average crystal size of zinc oxide particles after the calcination process. The absolute magnitude of the zeta potential for zinc oxide particles with a pyramidal rod morphology with an average diameter of 80-90 nm was 33.2 and for star-like morphology with an average diameter of 800-900 nm was 11.8. (c) 2022 Published by Elsevier Ltd.
引用
收藏
页数:10
相关论文
共 50 条
  • [21] Structural characterization of ZnO nanoparticles synthesized by co-precipitation and sol-gel method
    Vlazan, P.
    Irina-Moisescu, C.
    Miron, I.
    Sfirloaga, P.
    Grozescu, I.
    OPTOELECTRONICS AND ADVANCED MATERIALS-RAPID COMMUNICATIONS, 2015, 9 (9-10): : 1139 - 1142
  • [22] Structural and optical studies of yttrium oxide nanoparticles synthesized by co-precipitation method
    Srinivasan, Ramasamy
    Yogamalar, Rajeswari
    Bose, Arumugam Chandra
    MATERIALS RESEARCH BULLETIN, 2010, 45 (09) : 1165 - 1170
  • [23] Structural and Biological Investigation of Green Synthesized Silver and Zinc Oxide Nanoparticles
    S. P. Vinay
    N. Chandrasekhar
    Journal of Inorganic and Organometallic Polymers and Materials, 2021, 31 : 552 - 558
  • [24] Structural and Biological Investigation of Green Synthesized Silver and Zinc Oxide Nanoparticles
    Vinay, S. P.
    Chandrasekhar, N.
    JOURNAL OF INORGANIC AND ORGANOMETALLIC POLYMERS AND MATERIALS, 2021, 31 (02) : 552 - 558
  • [25] Structural, spectroscopic and morphology studies on green synthesized ZnO nanoparticles
    Sarkar, Toton
    Kundu, Sani
    Ghorai, Gurupada
    Sahoo, Pratap Kumar
    Bhattacharjee, Ashis
    ADVANCES IN NATURAL SCIENCES-NANOSCIENCE AND NANOTECHNOLOGY, 2023, 14 (03)
  • [26] Effect of annealing on the conversion of ZnS to ZnO nanoparticles synthesized by the sol-gel method using zinc acetate and thiourea
    Wahab, Rizwan
    Ansari, S. G.
    Kim, Young-Soon
    Dhage, M. S.
    Seo, Hyung Kee
    Song, Minwu
    Shin, Hyung-Shik
    METALS AND MATERIALS INTERNATIONAL, 2009, 15 (03) : 453 - 458
  • [27] Synthesis and Characterization of ZnO Nanoparticles in the Method of Precipitation
    Wang, Liqin
    Yang, Xiangni
    Han, Yang
    Zhang, Ruijun
    Yang, Yulin
    ADVANCED MATERIALS AND COMPUTER SCIENCE, PTS 1-3, 2011, 474-476 : 1725 - +
  • [28] Impact of annealing temperature on structural, optical, and morphological properties of zno nanoparticles synthesized by a simple precipitation method
    Deshmukh L.D.
    Chavan K.B.
    Nanoscience and Nanotechnology - Asia, 2021, 11 (02) : 204 - 210
  • [29] Effect of particle shape and size on the morphology and optical properties of zinc oxide synthesized by the polyol method
    Alves, T. E. P.
    Kolodziej, C.
    Burda, C.
    Franco, A., Jr.
    MATERIALS & DESIGN, 2018, 146 : 125 - 133
  • [30] An investigation into the influence of zinc precursor on the microstructural, photoluminescence, and gas-sensing properties of ZnO nanoparticles
    Catto, Ariadne C.
    da Silva, Luis F.
    Bernardi, Maria I. B.
    Li, Maximo S.
    Longo, Elson
    Lisboa-Filho, Paulo N.
    Nascimento, Otaciro R.
    Mastelaro, Valmor R.
    JOURNAL OF NANOPARTICLE RESEARCH, 2014, 16 (12)