Modeling of acetophenone hydrogenation over a Rh/C catalyst in a slurry airlift reactor

被引:13
作者
Bergault, I [1 ]
Joly-Vuillemin, C
Fouilloux, P
Delmas, H
机构
[1] Lab Genie Chim, Toulouse, France
[2] CPE Lyon, Lab Genie Procedes Catalyt, Villeurbanne, France
关键词
multiphase reactors; heterogeneous catalysis; airlift; deactivation;
D O I
10.1016/S0920-5861(98)00370-8
中图分类号
O69 [应用化学];
学科分类号
081704 ;
摘要
The hydrogenation of acetophenone in a slurry airlift reactor was conducted over a wide range of operating conditions. An important deactivation of the catalyst was experimentally observed and an empirical deactivation law was optimized. The deactivation rate constant increases with the inlet concentration and gas flow rate and decreases with the catalyst loading. The product selectivity measured in the slurry airlift reactor did not fit well with the computed one. The computation was performed using the results of the kinetic and hydrodynamic studies. A sensitivity analysis pointed out that the mass transfer is not limited. To perform a good fit with the experiments it was necessary to change some rate constants. This readjustment was justified by the difference in catalyst pretreatment between the continuous and the semi-batch reactor where significant catalyst pretreatment effects were shown. (C) 1999 Elsevier Science B.V. All rights reserved.
引用
收藏
页码:161 / 174
页数:14
相关论文
共 29 条
  • [1] BARINOV NS, 1973, J APPL CHEM-USSR+, V46, P940
  • [2] BARINOV NS, 1969, ZH PRIKL KHIM, V42, P2398
  • [3] BARINOV NS, 1973, IZV SIB OTD AN KHIM, V6, P507
  • [4] BARINOV NS, 1969, ZH PRIKL KHIM, V42, P2613
  • [5] BERGAULT I, 1997, THESIS TOULOUSE FRAN
  • [6] Catalytic hydrogenation of acetophenone over ruthenium catalysts
    Cerveny, L
    Dobrovolna, Z
    Belohlav, Z
    Kluson, P
    [J]. COLLECTION OF CZECHOSLOVAK CHEMICAL COMMUNICATIONS, 1996, 61 (05) : 764 - 769
  • [7] COSMONTANYI G, 1973, REV ROUM CHIM, V18, P1367
  • [8] SIGNIFICANCE OF LIQUID-FILM COEFFICIENTS IN GAS ABSORPTION
    DANCKWERTS, PV
    [J]. INDUSTRIAL AND ENGINEERING CHEMISTRY, 1951, 43 (06): : 1460 - 1467
  • [9] Deckwer W. D., 1992, BUBBLE COLUMN REACTO
  • [10] DELAMO FB, 1991, INGENIERIA QUIMICA M, V23, P115