Effect of Fulvic Acid in Landfill Leachate Membrane Concentrate on Evaporation Process

Landfill leachate membrane concentrate (LLMC) poses risks to the environment and is commonly treated by evaporation. As the main component of the dissolved organic matter in LLMC, fulvic acid (FA) was selected as a representative to investigate its effect on evaporation and the removal efficiency by pretreatment in this study. According to the water quality indexes and three-dimensional fluorescence spectra of LLMC samples collected from five landfills in China, the concentration of total organic carbon in LLMC was 700-2500 mg.L-1, in which FA accounted for 50-85%. The boiling point and viscosity of the configured FA-NaCl-Na2SO 4 solution both increased significantly when FA was concentrated 20 times (approximately 30,000 mg.L-1). Due to the presence of FA, the violent frothing phenomenon appeared at above 70 degrees C in evaporation, and the solubility of CaSO4 center dot 2H(2)O in FA-NaCl-Na2SO4 solution was significantly lower than that without FA. All these results indicated that the high FA concentration in LLMC could lead to decreased heat transfer coefficient and evaporation capacity during evaporation. Therefore, the softening pretreatment including the addition of Ca(OH)(2), Na2CO3, and coagulants was employed to reduce the hardness and FA concentration. After the softening experiments, the removal efficiency of FA was >95% for the configured LLMC sample, while for the actual LLMC sample collected from landfills, the removal efficiency of FA and chemical oxygen demand could reach >80% and about 30%, respectively. The remaining concentration of FA in LLMC was about 200 mg.L-1, and the recovery efficiency of clean water could be 90% in the evaporation process. This research has important guiding significance for the evaporation treatment of LLMC.