Response improvement for In2O3-TiO2 thick film gas sensors

被引：18
作者：
Zhang, Mao Lin [1 ]
Song, Jian Ping [1 ]
Yuan, Zhan Heng [1 ]
Zheng, Cheng [1 ]
机构：
[1] Xi An Jiao Tong Univ, State Lab Fine Funct Elect Mat & Devices, Sch Elect & Informat Engn, Xian 710049, Shaanxi, Peoples R China
来源：
CURRENT APPLIED PHYSICS | 2012年 / 12卷 / 03期
关键词：
In2O3-TiO2; Gas sensor; Response time; Platinum modified; SENSITIVITY; OXIDE; NO2; SELECTIVITY; MECHANISM;
D O I：
10.1016/j.cap.2011.10.004
中图分类号：
T [工业技术];
学科分类号：
08 ;
摘要：
In2O3 is introduced into TiO2 by sol-gel method to improve the response/recovery rate and expand the operating temperature, when the In2O3-TiO2 mixed system is exposed to H-2/O-2. The sensor is fabricated by thick film technology. Influence of In2O3 on the film phase composition, microstructure and sensing characteristics is discussed. Dynamic response properties show that the operating temperature of the mixed system is at 500-800 degrees C, which is about 600-800 degrees C for pure TiO2. Response time of the sensor is about 200-260 ms (millisecond) while recovery time is in a narrow range of 60-280 ms at 600-800 degrees C. The promoting mechanism is suggested to arise from the introduction of In2O3 and grain size effect of the sensing film. Then In2O3-TiO2 thick films are surface-modified by Pt using chloroplatinic acid. The promoting effect of Pt dispersed on the mixed system is also investigated. (C) 2011 Elsevier B. V. All rights reserved.
引用
收藏
页码：678 / 683
页数：6
相关论文
共 50 条
  • [31] High Response Gas Sensors for Formaldehyde Based on Er-doped In2O3 Nanotubes
    Wang, Xuesong
    Zhang, Jinbao
    Wang, Lianyuan
    Li, Shouchun
    Liu, Li
    Su, Chang
    Liu, Lili
    JOURNAL OF MATERIALS SCIENCE & TECHNOLOGY, 2015, 31 (12) : 1175 - 1180
  • [32] Effects of SnO2 Doping on the Performance of ZnO Porous Thick Film Gas Sensors
    Xu, Hongyan
    Song, Yuntao
    Cui, Deliang
    FUNCTIONAL AND ELECTRONIC MATERIALS, 2011, 687 : 55 - +
  • [33] Fast response thin film SnO2 gas sensors operating at room temperature
    Wang, H. C.
    Li, Y.
    Yang, M. J.
    SENSORS AND ACTUATORS B-CHEMICAL, 2006, 119 (02) : 380 - 383
  • [34] Ammonia gas sensing properties of Cr2O3 activated ZrO2 thick film resistors
    Deshmukh, Sudhakar B.
    Patil, Ganesh E.
    Bari, Ramesh H.
    Jain, Gotan H.
    2012 SIXTH INTERNATIONAL CONFERENCE ON SENSING TECHNOLOGY (ICST), 2012, : 517 - 526
  • [35] Preparation of Mesoporous and/or Macroporous SnO2-Based Powders and Their Gas-Sensing Properties as Thick Film Sensors
    Yuan, Luyang
    Hyodo, Takeo
    Shimizu, Yasuhiro
    Egashira, Makoto
    SENSORS, 2011, 11 (02) : 1261 - 1276
  • [36] Response and characteristics of TiO2/perovskite heterojunctions for CO gas sensors
    Hsu, Kuo-Chin
    Fang, Te-Hua
    Hsiao, Yu-Jen
    Wu, Pei-Che
    JOURNAL OF ALLOYS AND COMPOUNDS, 2019, 794 : 576 - 584
  • [37] Response of TiO2/MWCNT/B2O3 gas sensor to hydrogen using different organic binder
    Chachuli, Siti Amaniah Mohd
    Hamidon, Mohd Nizar
    Mamat, Md Shuhazlly
    Ertugrui, Mehmet
    Abdullah, Nor Hapishah
    MATERIALS SCIENCE IN SEMICONDUCTOR PROCESSING, 2019, 99 : 140 - 148
  • [38] Effect of processing and palladium doping on the properties of tin oxide based thick film gas sensors
    Choudhary, Meenakshi
    Mishra, V. N.
    Dwivedi, R.
    JOURNAL OF MATERIALS SCIENCE-MATERIALS IN ELECTRONICS, 2014, 25 (03) : 1331 - 1340
  • [39] Sensitivity of β Ga2O3 thin film oxygen gas sensors at high temperature
    Bartic, Marilena
    Baban, Cristian-Ioan
    Ogita, Masami
    Isai, Masaaki
    TRANSACTIONS OF THE MATERIALS RESEARCH SOCIETY OF JAPAN, VOL 32, NO 4, 2007, 32 (04): : 1195 - 1198
  • [40] Transient response of thick-film tin oxide gas-sensors to multicomponent gas mixtures
    Llobet, E
    Vilanova, X
    Brezmes, J
    Sueiras, JE
    Correig, X
    SENSORS AND ACTUATORS B-CHEMICAL, 1998, 47 (1-3) : 104 - 112
12345