Response improvement for In2O3-TiO2 thick film gas sensors

被引：18
作者：
Zhang, Mao Lin [1 ]
Song, Jian Ping [1 ]
Yuan, Zhan Heng [1 ]
Zheng, Cheng [1 ]
机构：
[1] Xi An Jiao Tong Univ, State Lab Fine Funct Elect Mat & Devices, Sch Elect & Informat Engn, Xian 710049, Shaanxi, Peoples R China
来源：
CURRENT APPLIED PHYSICS | 2012年 / 12卷 / 03期
关键词：
In2O3-TiO2; Gas sensor; Response time; Platinum modified; SENSITIVITY; OXIDE; NO2; SELECTIVITY; MECHANISM;
D O I：
10.1016/j.cap.2011.10.004
中图分类号：
T [工业技术];
学科分类号：
08 ;
摘要：
In2O3 is introduced into TiO2 by sol-gel method to improve the response/recovery rate and expand the operating temperature, when the In2O3-TiO2 mixed system is exposed to H-2/O-2. The sensor is fabricated by thick film technology. Influence of In2O3 on the film phase composition, microstructure and sensing characteristics is discussed. Dynamic response properties show that the operating temperature of the mixed system is at 500-800 degrees C, which is about 600-800 degrees C for pure TiO2. Response time of the sensor is about 200-260 ms (millisecond) while recovery time is in a narrow range of 60-280 ms at 600-800 degrees C. The promoting mechanism is suggested to arise from the introduction of In2O3 and grain size effect of the sensing film. Then In2O3-TiO2 thick films are surface-modified by Pt using chloroplatinic acid. The promoting effect of Pt dispersed on the mixed system is also investigated. (C) 2011 Elsevier B. V. All rights reserved.
引用
收藏
页码：678 / 683
页数：6
相关论文
共 50 条
  • [21] Synthesis, Characterization and Performance of Pure and Surface modified BaSnO3 with TiO2 thick film resistor as a gas sensor
    Patil, Narendra
    Jain, Gotan H.
    Gaikwad, Vishwas
    2012 SIXTH INTERNATIONAL CONFERENCE ON SENSING TECHNOLOGY (ICST), 2012, : 704 - 708
  • [22] Investigation of gas sensor based on In2O3:Ga2O3 film
    M. S. Aleksanyan
    V. M. Arakelyan
    V. M. Aroutiounian
    G. E. Shahnazaryan
    Journal of Contemporary Physics (Armenian Academy of Sciences), 2011, 46 : 86 - 92
  • [23] Gas Sensors on Ga2O3-In2O3 Thin Films
    Kozlov, A. G.
    Krivozubov, O. V.
    Kurdukova, E. A.
    Lila, M. N.
    2012 28TH INTERNATIONAL CONFERENCE ON MICROELECTRONICS (MIEL), 2012, : 165 - 168
  • [24] Al2O3 Modified ZnO Composite Thick Film for Ethanol Gas Sensing
    Rane, Sapana
    Gosavi, Suresh
    Awate, Shubhangi
    Uamrji, Govind
    Arbuj, Sudhir
    Rane, Sunit
    2015 2ND INTERNATIONAL SYMPOSIUM ON PHYSICS AND TECHNOLOGY OF SENSORS, 2015, : 307 - 309
  • [25] Effects of MWCNTs/graphene nanoflakes/MXene addition to TiO2 thick film on hydrogen gas sensing
    Chachuli, Siti Amaniah Mohd
    Hamidon, Mohd Nizar
    Ertugrul, Mehmet
    Mamat, Md Shuhazlly
    Coban, Omer
    Tuzluca, Fatma Nur
    Yesilbag, Yasar Ozkan
    Shamsudin, N. H.
    JOURNAL OF ALLOYS AND COMPOUNDS, 2021, 882 (882)
  • [26] NO2 response of In2O3 thin film gas sensors prepared by sol-gel and vacuum thermal evaporation techniques
    Cantalini, C
    Wlodarski, W
    Sun, HT
    Atashbar, MZ
    Passacantando, M
    Santucci, S
    SENSORS AND ACTUATORS B-CHEMICAL, 2000, 65 (1-3) : 101 - 104
  • [27] TiO2/SnO2 and TiO2/CuO thin film nano-heterostructures as gas sensors
    Maziarz, Wojciech
    APPLIED SURFACE SCIENCE, 2019, 480 : 361 - 370
  • [28] Nano Ag-Doped In2O3 Thick Film: A Low-Temperature H2S Gas Sensor
    Chavan, D. N.
    Patil, G. E.
    Kajale, D. D.
    Gaikwad, V. B.
    Khanna, P. K.
    Jain, G. H.
    JOURNAL OF SENSORS, 2011, 2011
  • [29] H2S sensing characteristics of Pt-doped α-Fe2O3 thick film sensors
    Wang, Yan
    Wang, Shurong
    Zhao, Yingqiang
    Zhu, Baolin
    Kong, Fanhong
    Wang, Da
    Wu, Shihua
    Huang, Weiping
    Zhang, Shoumn
    SENSORS AND ACTUATORS B-CHEMICAL, 2007, 125 (01) : 79 - 84
  • [30] Cr2O3-activated ZnO thick film resistors for ammonia gas sensing operable at room temperature
    Patil, D. R.
    Patil, L. A.
    Patil, P. P.
    SENSORS AND ACTUATORS B-CHEMICAL, 2007, 126 (02) : 368 - 374
12345