Effects of sensing temperature on the gas sensing properties of copper phthalocyanine and copper tetra-tert-butyl phthalocyanine films

被引:32
|
作者
Lee, YL [1 ]
Hsiao, CY [1 ]
Chang, CH [1 ]
Yang, YM [1 ]
机构
[1] Natl Cheng Kung Univ, Dept Chem Engn, TW-70101 Tainan, Taiwan
关键词
phthalocyanine; vacuum deposition; gas sensor; sensing temperature;
D O I
10.1016/S0925-4005(03)00329-0
中图分类号
O65 [分析化学];
学科分类号
070302 ; 081704 ;
摘要
Copper phthalocyanine (CuPc) and copper tetra-tert-butyl phthalocyanine (CuTTBPc) were vacuum deposited onto alumina substrates. The surface morphology and crystalline structures of the films prepared by the two compounds were studied first. These films were then used for the experiments of NO2 sensing. The effects of gas sensing temperature, as well as the NO2 concentration, on the sensing properties were studied for both films. The experimental results show that both CuPc and CuTTBPc films exhibit fine-grain morphology and low crystallinity. Due to the tetra-tert-butyl (ttb) substitution on the periphery of phthalocyanine, CuTTBPc film has a larger lattice spacing, higher film resistance, and a higher recovery ratio in the NO2 sensing experiments. On the contrary, the response rate and sensitivity of a CuPc film are superior to that of a CuTTBPc film. By varying the sensing temperature, it was found that the elevation of sensing temperature can improve the sensing response, recovery ratio, and sensitivity of the sensing films. At high concentrations of NO2, a longer response time is required and the recovery ratio becomes smaller. In addition, the disadvantage caused by the elevation of NO2 concentration can also be improved by using an elevated sensing temperature. (C) 2003 Elsevier Science B.V. All rights reserved.
引用
收藏
页码:169 / 175
页数:7
相关论文
共 50 条
  • [1] Preparation and thermostable properties of Langmuir-Blodgett films of copper tetra-tert-butyl phthalocyanine complex
    Emelyanov, YL
    Khatko, VV
    Tomchenko, AA
    SYNTHETIC METALS, 1996, 79 (03) : 173 - 175
  • [2] Annealing effects on the gas sensing properties of copper phthalocyanine films
    Lee, YL
    Hsiao, CY
    Hsiao, RH
    THIN SOLID FILMS, 2004, 468 (1-2) : 280 - 284
  • [3] ELECTRICAL AND STRUCTURAL STUDIES ON COPPER TETRA-TERT-BUTYL PHTHALOCYANINE LANGMUIR-BLODGETT-FILMS
    HANN, RA
    GUPTA, SK
    FRYER, JR
    EYRES, BL
    THIN SOLID FILMS, 1985, 134 (1-3) : 35 - 42
  • [4] Substrates effects on the growth behavior of Copper tetra-tert-butyl phthalocyanine films studied by atomic force microscopy
    Lee, YL
    Wu, HY
    Chang, CH
    Yang, YM
    THIN SOLID FILMS, 2003, 423 (02) : 169 - 177
  • [5] Gas sensing characteristics of copper phthalocyanine films: effects of film thickness and sensing temperature
    Lee, YL
    Sheu, CY
    Hsiao, RH
    SENSORS AND ACTUATORS B-CHEMICAL, 2004, 99 (2-3) : 281 - 287
  • [6] Investigation of gas-sensing properties of copper phthalocyanine films
    Basova, T.
    Tsargorodskaya, A.
    Nabok, A.
    Hassan, A. K.
    Gurek, A. G.
    Gumus, G.
    Ahsen, V.
    MATERIALS SCIENCE & ENGINEERING C-BIOMIMETIC AND SUPRAMOLECULAR SYSTEMS, 2009, 29 (03): : 814 - 818
  • [7] Fabrication and morphology of mixed copper tetra-tert-butyl phthalocyanine/arachidic acid Langmuir-Blodgett films
    Sheu, Ching-Wen
    Chang, Chien-Hsiang
    Lee, Yuh-Lang
    Yang, Yu-Min
    Maa, Jer-Ru
    2002, Chinese Institute of Chemical Engineers (33):
  • [8] Fabrication and morphology of mixed copper tetra-tert-butyl phthalocyanine/arachidic acid Langmuir-Blodgett films
    Sheu, CW
    Chang, CH
    Lee, YL
    Yang, YM
    Maa, JR
    JOURNAL OF THE CHINESE INSTITUTE OF CHEMICAL ENGINEERS, 2002, 33 (06): : 573 - 580
  • [9] Tetra-tert-butyl copper phthalocyanine-based QCM sensor for toluene detection in air at room temperature
    Kumar, A.
    Brunet, J.
    Varenne, C.
    Ndiaye, A.
    Pauly, A.
    Penza, M.
    Alvisi, M.
    SENSORS AND ACTUATORS B-CHEMICAL, 2015, 210 : 398 - 407
  • [10] Effects of substrate temperature on the film characteristics and gas-sensing properties of copper phthalocyanine films
    Lee, YL
    Tsai, WC
    Maa, JR
    APPLIED SURFACE SCIENCE, 2001, 173 (3-4) : 352 - 361