Influence of electropulsing treatment on microstructure and mechanical properties of cold-rolled Mg-9Al-1Zn alloy strip

被引：57
作者：
Jiang, Yanbin [1 ,2 ]
Guan, Lei [3 ]
Tang, Guoyi [4 ]
Shek, Chanhung [5 ]
Zhang, Zhihao [1 ,2 ]
机构：
[1] Univ Sci & Technol Beijing, Key Lab Adv Mat Proc MOE, Beijing 100083, Peoples R China
[2] Univ Sci & Technol Beijing, Inst Adv Mat & Technol, Beijing 100083, Peoples R China
[3] Inst Aeronaut Mat, Lab Struct Steel Funct Mat & Heat Treatment Proc, Beijing 100095, Peoples R China
[4] Tsinghua Univ, Adv Mat Inst, Grad Sch Shenzhen, Shenzhen 518055, Peoples R China
[5] City Univ Hong Kong, Dept Phys & Mat Sci, Kowloon Tong, Hong Kong, Peoples R China
来源：
MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING | 2011年 / 528卷 / 16-17期
基金：
中国国家自然科学基金;
关键词：
Magnesium alloy; Electropulsing treatment; Recrystallization; Mechanical properties; ELECTRIC-CURRENT PULSES; ULTRAFINE-GRAINED MICROSTRUCTURE; AZ31 MAGNESIUM ALLOY; TEXTURE EVOLUTION; CURRENT-DENSITY; MG ALLOY; PHASE; RECRYSTALLIZATION; SLIP; DEFORMATION;
D O I：
10.1016/j.msea.2011.03.095
中图分类号：
TB3 [工程材料学];
学科分类号：
0805 ; 080502 ;
摘要：
Influences of electropulsing treatment (EFT) on microstructure and mechanical properties of cold-rolled Mg-9Al-1Zn alloy strip were studied. EPT was found to accelerate the recrystallization of cold-rolled Mg-9Al-1Zn alloy strip at a relatively low temperature, and obtain fine microstructure of quasi-single-phase-recrystallized grains. The EPT-induced microstructural changes weakened the intensity of the basal fiber texture, and increased elongation to failure remarkably with a decrease in tensile strength. Fracture surface analysis showed that transition from intergranular brittle facture to transgranular dimple fracture took place with an increase in frequency of EPT. The rapid recrystallization behaviour of the Mg-9Al-1Zn alloy strip under EPT was attributed to the enhancement of nucleation rate and atomic diffusion resulting from the coupling of the thermal and athermal effects. It is supposed that EFT can provide a highly efficient method for the intermediate-softening annealing of magnesium alloys sheet/strips. (C) 2011 Elsevier B.V. All rights reserved.
引用
收藏
页码：5627 / 5635
页数：9
相关论文
共 41 条
  • [11] Fracture behavior and mechanical properties of Mg-4Y-2Nd-1Gd-0.4Zr (wt.%) alloy
    Fu Penghuai
    Peng Liming
    Hang Haiyan
    Zhang Zhenyan
    Zhai Chunquan
    [J]. MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2008, 486 (1-2): : 572 - 579
  • [12] Texture evolution in cold-rolled AZ31 magnesium alloy during electropulsing treatment
    Guan, Lei
    Tang, Guoyi
    Jiang, Yanbin
    Chu, Paul K.
    [J]. JOURNAL OF ALLOYS AND COMPOUNDS, 2009, 487 (1-2) : 309 - 313
  • [13] Grain size effects on the tensile properties and deformation mechanisms of a magnesium alloy, AZ31B, sheet
    Jain, A.
    Duygulu, O.
    Brown, D. W.
    Tome, C. N.
    Agnew, S. R.
    [J]. MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING, 2008, 486 (1-2): : 545 - 555
  • [14] Microstructure and texture evolution of the cold-rolled AZ91 magnesium alloy strip under electropulsing treatment
    Jiang, Yanbin
    Tang, Guoyi
    Shek, Chanhung
    Liu, Wei
    [J]. JOURNAL OF ALLOYS AND COMPOUNDS, 2011, 509 (11) : 4308 - 4313
  • [15] Effect of electropulsing treatment on microstructure and tensile fracture behavior of aged Mg-9Al-1Zn alloy strip
    Jiang, Yanbin
    Tang, Guoyi
    Shek, Chanhung
    Zhu, Yaohua
    [J]. APPLIED PHYSICS A-MATERIALS SCIENCE & PROCESSING, 2009, 97 (03): : 607 - 615
  • [16] On the thermodynamics and kinetics of electropulsing induced dissolution of β-Mg17Al12 phase in an aged Mg-9Al-1Zn alloy
    Jiang, Yanbin
    Tang, Guoyi
    Shek, Chanhung
    Zhu, Yaohua
    Xu, Zhuohui
    [J]. ACTA MATERIALIA, 2009, 57 (16) : 4797 - 4808
  • [17] JIANG YB, 2010, THESIS TSINGHUA U BE, P99
  • [18] Texture development and its effect on mechanical properties of an AZ61 Mg alloy fabricated by equal channel angular pressing
    Kim, WJ
    Hong, SI
    Kim, YS
    Min, SH
    Jeong, HT
    Lee, JD
    [J]. ACTA MATERIALIA, 2003, 51 (11) : 3293 - 3307
  • [19] Mechanical properties and microstructures of an AZ61 Mg Alloy produced by equal channel angular pressing
    Kim, WJ
    An, CW
    Kim, YS
    Hong, SI
    [J]. SCRIPTA MATERIALIA, 2002, 47 (01) : 39 - 44
  • [20] The activity of non-basal slip systems and dynamic recovery at room temperature in fine-grained AZ31B magnesium alloys
    Koike, J
    Kobayashi, T
    Mukai, T
    Watanabe, H
    Suzuki, M
    Maruyama, K
    Higashi, K
    [J]. ACTA MATERIALIA, 2003, 51 (07) : 2055 - 2065
12345