Exergy analysis of the flue gas pre-dried lignite-fired power system based on the boiler with open pulverizing system

被引：47

作者：

Han, Xiaoqu ^{[1
]}

Liu, Ming ^{[1
]}

Wu, Kaili ^{[1
]}

Chen, Weixiong ^{[1
]}

Xiao, Feng ^{[2
]}

Yan, Junjie ^{[1
]}

机构：

[1] Xi An Jiao Tong Univ, State Key Lab Multiphase Flow Power Engn, Xian 710049, Peoples R China

[2] China Power Engn Consulting Grp Corp, Northeast Elect Power Design Inst, Changchun 130021, Peoples R China

来源：

ENERGY | 2016年 / 106卷

基金：

中国国家自然科学基金;

关键词：

Exergy analysis; Flue gas pre-drying; Lignite; Open pulverizing system; Simulation; WASTE HEAT-RECOVERY; THERMODYNAMIC ANALYSIS; PERFORMANCE ANALYSES; GENERATION SYSTEM; PLANT; CYCLE; OPTIMIZATION; DESIGN; ENERGY; INTEGRATION;

D O I：

10.1016/j.energy.2016.03.047

中图分类号：

O414.1 [热力学];

学科分类号：

摘要：

This paper deals with an exergetic analysis of the flue gas pre-dried lignite-fired power system (FPLPS) based on the boiler with open pulverizing system (OPSB) to explore the energy-saving potential of the FPLPS. A steady-state simulation was performed to obtain thermodynamic properties of process streams in a 600 MW unit. Results indicated that the plant efficiency of the FPLPS was relatively 3.42% higher than that of the conventional lignite -fired power system (CLPS). The improvement benefited from the integration of the flue gas dryer with the OPS, in which the dryer exhaust gas was separated from coal powders and prevented from recycling in the furnace. Consequently, the exergy destruction in the combustion process was reduced by 232%-pts for increased flame temperature, and the exergy loss of the boiler exhaust gas was reduced by 0.68%-pts for decreased temperature. Moreover, the dryer exergy efficiency was only 20.20% due to considerable exergy destructions in the moisture evaporation and the mixing of drying agents. The proposed retrofitting option by extracting cold flue gas from the economizer outlet could increase the plant efficiency by 0.33% relatively. Finally, attempts were made to examine the influence of varying pre-drying parameters on system performances. (C) 2016 Elsevier Ltd. All rights reserved.

引用

页码：285 / 300

页数：16

共 49 条

[1] Energy and exergy analysis of a super critical thermal power plant at various load conditions under constant and pure sliding pressure operation
Adibhatla, Sairam
Kaushik, S. C.
[J]. APPLIED THERMAL ENGINEERING, 2014, 73 (01) : 51 - 65
[2] A review on exergy analysis of drying processes and systems
Aghbashlo, Mortaza
Mobli, Hossein
Rafiee, Shahin
Madadlou, Ashkan
[J]. RENEWABLE & SUSTAINABLE ENERGY REVIEWS, 2013, 22 : 1 - 22
[3] Exergy, exergoeconomic and environmental analyses and evolutionary algorithm based multi-objective optimization of combined cycle power plants
Ahmadi, Pouria
Dincer, Ibrahim
Rosen, Marc A.
[J]. ENERGY, 2011, 36 (10) : 5886 - 5898
[4] Exergoenvironmental analysis and optimization of a cogeneration plant system using Multimodal Genetic Algorithm (MGA)
Ahmadi, Pouria
Dincer, Ibrahim
[J]. ENERGY, 2010, 35 (12) : 5161 - 5172
[5] [Anonymous], TOPMERET MOD TECHN H
[6] Thermodynamic analysis and comparison of retrofitting pre-drying concepts at existing lignite power plants
Atsonios, Konstantinos
Violidakis, Ioannis
Agraniotis, Michalis
Grammelis, Panagiotis
Nikolopoulos, Nikos
Kakaras, Emmanuel
[J]. APPLIED THERMAL ENGINEERING, 2015, 74 : 165 - 173
[7] Bejan A, 1982, J APPL MEH, V50
[8] Burnard K., 2011, Information Paper
[9] Second law analysis of a waste heat recovery based power generation system
Butcher, C. J.
Reddy, B. V.
[J]. INTERNATIONAL JOURNAL OF HEAT AND MASS TRANSFER, 2007, 50 (11-12) : 2355 - 2363
[10] The exergy and energy level analysis of a combined cooling, heating and power system driven by a small scale gas turbine at off design condition
Chen, Qiang
Han, Wei
Zheng, Jian-jiao
Sui, Jun
Jin, Hong-guang
[J]. APPLIED THERMAL ENGINEERING, 2014, 66 (1-2) : 590 - 602

← 1 2 3 4 5 →