DETERMINATION OF VOLATILE ORGANIC COMPOUNDS IN PALM-BASED POLYURETHANE FOAMS USING STATIC HEADSPACE GAS CHROMATOGRAPHY MASS SPECTROMETER

被引:0
作者
Azmil, Mohd M. N. [1 ]
'Ain, Nurul H. [1 ]
Adnan, S. [1 ]
Devi, Kosheela P. P. [1 ]
Maznee, Tuan Noor T., I [1 ]
Hazimah, A. H. [1 ]
机构
[1] Malaysian Palm Oil Board, Persiaran Inst 6, Kajang 43000, Selangor, Malaysia
来源
JOURNAL OF OIL PALM RESEARCH | 2015年 / 27卷 / 03期
关键词
static headspace; volatile organic compounds; polyurethane foams; volatile amines; gas chromatography;
D O I
暂无
中图分类号
TS2 [食品工业];
学科分类号
0832 ;
摘要
Volatile organic compounds (VOC), in combination with other environmental factors, are potential health and environmental hazards. Studies have shown that an abundance of VOC were released from home and personal care products, building and transportation materials. A direct method employing a static headspace sampler (HS), a gas chromatography (GC) and a mass spectrometer detector (MS) has been developed and validated for semi-quantitative analysis of VOC emitted from palm-based polyurethane (PU) foams. In this method, PU foams were heated and the volatiles were extracted and then analysed by GC-MS. The conditions of the HS-GC-MS system were optimised to achieve high recovery and sensitivity. Method validation was performed and it demonstrated an average recovery of 95% and 89% for DABCO 33LV and NIAX A1 (volatile amines), respectively. The limit of detection was 0.66 ppm while the limit of quantitation was 1.32 ppm. Analyses performed on commercial and palm-based PU foams showed that the concentration of overall VOC detected did not exceed the limits set by car manufacturers (maximum at 50 ppm). The VOC detected were mainly DABCO 33LV and NIAX A1. The method developed was found to be effective and considered rapid without laborious sample preparation and can be used by PU manufacturers to monitor the level of VOC in their products.
引用
收藏
页码:273 / 281
页数:9
相关论文
共 50 条
[31]   Sorption study of 25 volatile organic compounds in several Mediterranean soils using headspace-gas chromatography-mass spectrometry [J].
Serrano, A. ;
Gallego, A. .
JOURNAL OF CHROMATOGRAPHY A, 2006, 1118 (02) :261-270
[32]   Chemical composition of volatile compounds in two red seaweeds, Pterocladiella capillacea and Osmundaria obtusiloba, using static headspace gas chromatography mass spectrometry [J].
de Alencar, Daniel Barroso ;
Diniz, Jaecio Carlos ;
Serafim Rocha, Simone Alves ;
dos Santos Pires-Cavalcante, Kelma Maria ;
Freitas, Jefferson Oliveira ;
Nagano, Celso Shiniti ;
Sampaio, Alexandre Holanda ;
Saker-Sampaio, Silvana .
JOURNAL OF APPLIED PHYCOLOGY, 2017, 29 (03) :1571-1576
[33]   Determination of volatile organic compounds in water using headspace knotted hollow fiber microextraction [J].
Chen, Pai-Shan ;
Tseng, Yu-Hsiang ;
Chuang, Yuh-Lin ;
Chen, Jung-Hsuan .
JOURNAL OF CHROMATOGRAPHY A, 2015, 1395 :41-47
[34]   Analysis of Volatile Organic Compounds from Dendranthema indicum var. aromaticum by Headspace Gas Chromatography-Mass Spectrometry and Accurate Mass Measurement [J].
Wang, Cheng-Zhong ;
Su, Yue ;
Li, Dan ;
Cai, Bing ;
Guo, Yin-Long .
ANALYTICAL LETTERS, 2010, 43 (15) :2297-2310
[35]   Veracity on determination of volatile organic compounds in the air by portable gas chromatography-mass spectrometry [J].
Lu Yibing ;
Sun Xiaohui ;
Fu Qiang .
CHINESE JOURNAL OF CHROMATOGRAPHY, 2010, 28 (05) :470-475
[36]   Headspace solid-phase microextraction gas chromatography-mass spectrometry for the detection of volatile organic compounds released from Ganoderma boninense and oil palm wood [J].
Hilmi, Nur Hailini Zainol ;
Idris, Abu Seman ;
Azmil, Mohd Noor Mohd .
FOREST PATHOLOGY, 2019, 49 (04)
[37]   Analysis of volatile organic sulphur compounds in kraft liquors by full evaporation headspace gas chromatography [J].
Chai, XS ;
Liu, PH ;
Zhu, JY .
JOURNAL OF PULP AND PAPER SCIENCE, 2000, 26 (05) :167-172
[38]   Analysis of Volatile Organic Compounds in Printing and Plastic Packaging Materials of Instant Noodles by Headspace Gas Chromatography-Mass Spectrometry [J].
Xie Li ;
Yu Jiang ;
Ren Peng-Gang ;
Diao Sha-Sha ;
Li Shuang .
CHINESE JOURNAL OF ANALYTICAL CHEMISTRY, 2011, 39 (09) :1368-1372
[39]   Determination of volatile chlorinated hydrocarbons in water samples by static headspace gas chromatography with electron capture detection [J].
Li, Tiejun ;
Guo, Yuanming ;
Hu, Hongmei ;
Zhang, Xiaoning ;
Jin, Yanjian ;
Zhang, Xiaojun ;
Zhang, Yurong .
JOURNAL OF SEPARATION SCIENCE, 2016, 39 (02) :358-366
[40]   Discrimination and characterization of the volatile organic compounds of Acori tatarinowii rhizoma based on headspace-gas chromatography-ion mobility spectrometry and headspace solid phase microextraction-gas chromatography-mass spectrometry [J].
Wu, Xinlong ;
Li, Wei ;
Li, Chao ;
Yin, Jiaxin ;
Wu, Tong ;
Zhang, Min ;
Zhu, Limin ;
Chen, Hanjiang ;
Zhang, Xilian ;
Bie, Songtao ;
Li, Fangyi ;
Song, Xinbo ;
Gong, Xingchu ;
Yu, Heshui ;
Li, Zheng .
ARABIAN JOURNAL OF CHEMISTRY, 2022, 15 (11)