Mechanical, durability and economic performance of concrete incorporating fly ash and recycled aggregates

被引:25
作者
Nawaz, Muhammad Asad [1 ]
Qureshi, Liaqat Ali [1 ,2 ]
Ali, Babar [2 ]
Raza, Ali [1 ]
机构
[1] Univ Engn & Tech Nol, Civil Engn Dept, Taxila 47050, Pakistan
[2] Swedish Coll Engn & Technol, Civil Engn Dept, Wah Cantt 47060, Pakistan
来源
SN APPLIED SCIENCES | 2020年 / 2卷 / 02期
关键词
Hardened properties; Workability; Economy; Fly ash; Recycled aggregate concrete; Cost to strength ratio; Chloride migration coefficient; Transportation scenario; HIGH-VOLUME; WASTE; CONSTRUCTION; STRENGTH;
D O I
10.1007/s42452-020-1960-8
中图分类号
O [数理科学和化学]; P [天文学、地球科学]; Q [生物科学]; N [自然科学总论];
学科分类号
07 ; 0710 ; 09 ;
摘要
This paper studies the impact of replacing natural coarse aggregates (NCA) with recycled coarse aggregates (RCA) and cement (OPC) with fly ash (FA), on properties and economy of concrete. RCA was obtained by crushing old concrete specimens. FA of low calcium type was used to partially replace OPC. A total of nine concrete mixes (including a reference mix) were prepared using 50% RCA, and 100% RCA with four different levels of FA (0% FA, 10% FA, 20% FA, 30% FA). Workability, fresh density, compressive strength, apparent porosity, and bulk density was measured to evaluate the performance of each mixture. Mixes with optimum levels of both RCA and FA reaching the compressive strength potential of reference mix at 90 days, were subjected to chloride migration testing. To ascertain the combined impact of RCA and FA on economic and strength performance of concrete, a cost to strength ratio (CSR) analysis was also performed on all mixes. Results of testing indicate that FA compensates the loss in workability of fresh concrete and improve the compressive strength of RCA concrete at 28 and 90 days. Negative influence of RCA on density and porosity is minimized by consumption of FA in concrete. Mixes with 50% RCA and 20-30% FA show better resistance against chloride penetration compared to that of the reference mix. CSR analysis suggests that FA must be used along with RCA in concrete in order to minimize the negative influence of RCA on both cost and strength.
引用
收藏
页数:10
相关论文
共 50 条
[31]   Mechanical, Durability, and Time-Dependent Properties of Recycled Aggregate Concrete with Fly Ash [J].
Surya, M. ;
Rao, V. V. L. Kanta ;
Lakshmy, Parameswaran .
ACI MATERIALS JOURNAL, 2015, 112 (05) :653-661
[32]   Mechanical and Durability Properties of Concrete Containing Recycled Concrete Aggregates [J].
Mahmood, Wajeeha ;
Khan, Asad-ur-Rehman ;
Ayub, Tehmina .
IRANIAN JOURNAL OF SCIENCE AND TECHNOLOGY-TRANSACTIONS OF CIVIL ENGINEERING, 2022, 46 (03) :2111-2130
[33]   EVALUATING THE EFFECTS OF COMBINED FLY ASH AND MARBLE COARSE AGGREGATES ON THE PROPERTIES AND DURABILITY OF CONCRETE [J].
Filali, Saloua ;
Nasser, Abdelkader .
JOURNAL OF ENGINEERING SCIENCE AND TECHNOLOGY, 2025, 20 (03) :704-722
[34]   DURABILITY OF CONCRETE CONTAINING RECYCLED ASPHALTIC CONCRETE AGGREGATE AND HIGH CALCIUM FLY ASH [J].
Chindaprasirt, Prinya ;
Kasemsiri, Pornnapa ;
Leekongbub, Sompron ;
Posi, Patcharapol .
INTERNATIONAL JOURNAL OF GEOMATE, 2020, 19 (74) :8-14
[35]   Mechanical and Durability Performance of Concrete Made with Waste Marble and Fly Ash [J].
Sancheti, Gaurav ;
Jain, Kishan Lal ;
Bhargava, Shruti .
JORDAN JOURNAL OF CIVIL ENGINEERING, 2020, 14 (03) :305-318
[36]   Mechanical properties and durability performance of reinforced concrete containing fly ash [J].
Chousidis, N. ;
Rakanta, E. ;
Ioannou, I. ;
Batis, G. .
CONSTRUCTION AND BUILDING MATERIALS, 2015, 101 :810-817
[37]   Mechanical and durability properties of recycled aggregate concretes containing fly ash [J].
Mei Ying-jun ;
Wu Jin-hang ;
Zheng Jian-hua .
ARCHITECTURE AND BUILDING MATERIALS, PTS 1 AND 2, 2011, 99-100 :654-659
[38]   Mechanical properties and durability of bio-blocks with recycled concrete aggregates [J].
Javadi, Armin Saeedi ;
Badiee, Hassan ;
Sabermahani, Mohsen .
CONSTRUCTION AND BUILDING MATERIALS, 2018, 165 :859-865
[39]   Influence of fly ash, glass fibers and wastewater on production of recycled aggregate concrete [J].
Raza, A. ;
Ali, B. ;
Haq, F. U. ;
Awais, M. ;
Jameel, M. S. .
MATERIALES DE CONSTRUCCION, 2021, 71 (343)
[40]   Mechanical performance of roller compacted concrete with recycled concrete aggregates [J].
Lopez-Uceda, Antonio ;
Agrela, Francisco ;
Cabrera, Manuel ;
Ayuso, Jesus ;
Lopez, Martin .
ROAD MATERIALS AND PAVEMENT DESIGN, 2018, 19 (01) :36-55