Molecular Dynamics Simulation on the Effect of MgO/Al2O3 Ratio on Structure and Properties of Blast Furnace Slag Under Different Basicity Conditions

被引：53

作者：

Jiang, Chunhe ^{[1
]}

Li, Kejiang ^{[1
]}

Zhang, Jianliang ^{[1
,2
]}

Qin, Qinghua ^{[1
]}

Liu, Zhengjian ^{[1
]}

Liang, Wang ^{[1
]}

Sun, Minmin ^{[1
]}

Wang, Ziming ^{[1
]}

机构：

[1] Univ Sci & Technol Beijing, Sch Met & Ecol Engn, 30 Xueyuan Rd, Beijing 100083, Peoples R China

[2] Univ Queensland, Sch Chem Engn, St Lucia, Qld 4072, Australia

来源：

METALLURGICAL AND MATERIALS TRANSACTIONS B-PROCESS METALLURGY AND MATERIALS PROCESSING SCIENCE | 2019年 / 50卷 / 01期

基金：

美国国家科学基金会; 加拿大创新基金会;

关键词：

MOLTEN COKE ASH; VISCOSITY; COAL; REDUCTION; CRYSTALS; FLUIDITY; BEHAVIOR; SYSTEM; AL2O3;

D O I：

10.1007/s11663-018-1450-1

中图分类号：

T [工业技术];

学科分类号：

08 ;

摘要：

The SiO2-Al2O3-CaO-MgO is the basic structural system of blast furnace slag and the composition directly affects the performance of the slag. Molecular dynamics simulations were carried out to analyze the local structure, structural unit, bond angle, transport properties, and enthalpy of the slag with the increase of MgO/Al2O3 mass ratio under different basicity conditions. It was found that the change of MgO/Al2O3 ratio does not affect the short-range order structure, but it will reduce the overall stability of the network structure. Through the analysis of the structural unit of the slag, it was found that the polymerization degree of the system decreases with the increase of MgO/Al2O3 ratio, indicating that the complex network structure of the system is partially depolymerized. Besides, the self-diffusion coefficients of each ion were concluded and the magnitudes were observed to be in the following order: Mg2+>Ca2+>Al3+>O2->Si4+. The diffusivity of the slag increases with the increase of MgO/Al2O3 ratio and the corresponding viscosity decreases. And the enthalpy of the slag is increased with the increase of MgO/Al2O3 ratio or basicity, therefore the fuel consumption should also be properly adjusted during the operation of blast furnace to ensure the target temperature.

引用

页码：367 / 375

页数：9

共 37 条

[1] Structure and Crystallization of Alkaline-Earth Aluminosilicate Glasses: Prevention of the Alumina-Avoidance Principle [J].

Allu, Amarnath R. ;

Gaddam, Anuraag ;

Ganisett, Sudheer ;

Balaji, Sathravada ;

Siegel, Renee ;

Mather, Glenn C. ;

Fabian, Margit ;

Pascual, Maria J. ;

Ditaranto, Nicoletta ;

Milius, Wolfgang ;

Senker, Juergen ;

Agarkov, Dmitrii A. ;

Kharton, Vladislav V. ;

Ferreira, Jose M. F. .

JOURNAL OF PHYSICAL CHEMISTRY B, 2018, 122 (17) :4737-4747

[2] FactSage thermochemical software and databases, 2010-2016 [J].

Bale, C. W. ;

Belisle, E. ;

Chartrand, P. ;

Decterov, S. A. ;

Eriksson, G. ;

Gheribi, A. E. ;

Hack, K. ;

Jung, I. -H. ;

Kang, Y. -B. ;

Melancon, J. ;

Pelton, A. D. ;

Petersen, S. ;

Robelin, C. ;

Sangster, J. ;

Spencer, P. ;

Van Ende, M-A. .

CALPHAD-COMPUTER COUPLING OF PHASE DIAGRAMS AND THERMOCHEMISTRY, 2016, 54 :35-53

[3]

Einstein A., 1956, J JOYCE Q, V35, P155

[4] LOCAL-STRUCTURE OF SILICATE-GLASSES [J].

GREAVES, GN ;

FONTAINE, A ;

LAGARDE, P ;

RAOUX, D ;

GURMAN, SJ .

NATURE, 1981, 293 (5834) :611-616

[5] EXAFS AND THE STRUCTURE OF GLASS [J].

GREAVES, GN .

JOURNAL OF NON-CRYSTALLINE SOLIDS, 1985, 71 (1-3) :203-217

[6]

Iida T., 2000, ISIJ INT, V40, ps110

[7] Molecular dynamics simulation of thermodynamic and structural properties of silicate glass: Effect of the alkali oxide modifiers [J].

Jabraoui, H. ;

Achhal, E. M. ;

Hasnaoui, A. ;

Garden, J. -L. ;

Vaills, Y. ;

Ouaskit, S. .

JOURNAL OF NON-CRYSTALLINE SOLIDS, 2016, 448 :16-26

[8] Interplay between non-bridging oxygen, triclusters, and fivefold Al coordination in low silica content calcium aluminosilicate melts [J].

Jakse, N. ;

Bouhadja, M. ;

Kozaily, J. ;

Drewitt, J. W. E. ;

Hennet, L. ;

Neuville, D. R. ;

Fischer, H. E. ;

Cristiglio, V. ;

Pasturel, A. .

APPLIED PHYSICS LETTERS, 2012, 101 (20)

[9] The effect of CaO(MgO) on the structure and properties of aluminosilicate system by molecular dynamics simulation [J].

Jiang, Chunhe ;

Li, Kejiang ;

Zhang, Jianliang ;

Qin, Qinghua ;

Liu, Zhengjian ;

Liang, Wang ;

Sun, Minmin ;

Wang, Ziming .

JOURNAL OF MOLECULAR LIQUIDS, 2018, 268 :762-769

[10]

Le Roux S, 2010, J APPL CRYSTALLOGR, V43, P181, DOI [10.1107/S0021889809051929, 10.1107/S00218898090511929]

← 1 2 3 4 →