Effect of temperature on the anaerobic thermophilic conversion of volatile fatty acids by dispersed and granular sludge

The effect of temperature on the rate of volatile fatty acid (VFA) conversion by thermophilic methanogenic sludge, cultivated at 55 degrees C, was studied using both batch activity tests and continuous flow experiments. The temperature dependence of acetate conversion in the range between 37-70 degrees C could be described by an Arrhenius derived model when dispersed sludge with a low specific activity was used. For this sludge the optimum acetate conversion rate was found at 65 degrees C. However, the maximum acetate utilization rate was not affected by temperature in the range between 50 degrees C to 65 degrees C when granular sludge with a high specific methanogenic activity was used. Crushing the granules led to a 2 to 3 fold increase in the maximum activity at 60-65 degrees C, indicating that the conversion rate was very likely limited by the diffusion rate of acetate into the granules. Similar results were obtained with butyrate as the substrate. The temperature dependence of the crushed granules was similar to that of the less active dispersed sludge. In contrast, the thermophilic propionate oxidation rate was highest with the intact granular sludge while a similar temperature dependence was found for both the granular and dispersed sludges. The affinity for VFA increased with decreasing temperature. This phenomenon was most pronounced for the granular sludge. The thermophilic treatment of a VFA-mixture in a UASB reactor appeared to be only slightly affected by temperature when moderately low loading rates were applied, i.e. 20 kg COD . m(-3). d(-1). However, temperature had a strong effect applying loading rates of 40-90 kg COD . m(-3). d(-1) accompanied with high effluent VFA concentrations. The results reveal a high thermostability of the thermophilic wastewater treatment process in the range 45-60 degrees C if ''high-rate'' reactors with a granular sludge bed are used.