Calcining temperature dependence of microwave dielectric properties of (1-x)ZnAl2O4 xTiO2 (x=0.21) ceramics

被引:16
作者
Lu, Wen-Zhong [1 ]
Lei, Wen [1 ]
Zu, Jian-Hua [1 ]
Liang, Fei [1 ]
机构
[1] Huazhong Univ Sci & Technol, Dept Elect Sci & Technol, Wuhan 430074, Peoples R China
来源
JAPANESE JOURNAL OF APPLIED PHYSICS PART 2-LETTERS & EXPRESS LETTERS | 2007年 / 46卷 / 29-32期
关键词
ceramics; dielectric properties; electron microscopy; X-ray diffraction; ZnAl2O4-TiO2;
D O I
10.1143/JJAP.46.L724
中图分类号
O59 [应用物理学];
学科分类号
摘要
(1 - x)ZnAl2O4-xTiO(2) (x = 0.21) ceramics were synthesized at 1500 degrees C using the solid-state reaction after the starting powders were calcined at 1050-1250 degrees C. The effects of calcining temperature on the microstructures, phase compositions, and microwave dielectric properties of the ceramics had been investigated. In the calcined (1 - x)ZnAl2O4-xTiO(2) (x = 0.21) powders, the amount of the secondary phase Zn2Ti3O8 decreases gradually with increasing calcining temperature and it disappears at more than 1150 degrees C. The epsilon(r) and Q . f values increase slowly with increasing calcining temperature and then decrease after reaching the maximum value at 1150 degrees C, whereas the tau(f) values are nearly independent of the calcining temperature and approach zero. When the calcining temperature reaches 1150 C, the optimal microwave dielectric properties of the (1 - x)ZnAl2O4-xTiO(2) (x = 0.21) ceramics can be exhibited with a epsilon(r) of 11.6, a Q . f of 74,000 GHz (at about 6.5 GHz), and a tau(f) of -0.4ppm/degrees C.
引用
收藏
页码:L724 / L726
页数:3
相关论文
共 50 条
[41]   Crystal structure and microwave dielectric properties of middle-temperature-sintered Mg2Si(1-x)VxO4 ceramics [J].
Zhifen Fu ;
Jianli Ma ;
Peng Liu ;
Yang Li ;
Xiaosen Zhang .
Journal of Electroceramics, 2016, 36 :82-86
[42]   Phase relation and microwave dielectric properties of xCaTiO3-(1-x)TiO2-3ZnTiO3 multiphase ceramics [J].
Zhao, Fei ;
Yue, Zhenxing ;
Lin, Yongzhao ;
Gui, Zhilun ;
Li, Longtu .
CERAMICS INTERNATIONAL, 2007, 33 (06) :895-900
[43]   Microwave dielectric properties of (1-x)MgO-x(0.8LiF-0.2CaF2) ceramics for low-temperature Co-fired ceramics [J].
Wang, Xiao-Hong ;
Jiang, Hai ;
Wang, Xiao-Chuan ;
Li, Zhen-Lin ;
Lu, Wen-Zhong .
CERAMICS INTERNATIONAL, 2015, 41 (09) :12310-12316
[44]   Structural evolution, sintering behavior and microwave dielectric properties of (1-x)Li2TiO3 + xLiF ceramics [J].
Ding Yaomin ;
Bian Jianjiang .
MATERIALS RESEARCH BULLETIN, 2013, 48 (08) :2776-2781
[45]   GPS patch antenna performance by modification of Zn(1-x)CaxAl2O4-based microwave dielectric ceramics [J].
Jalal, Wan Nasarudin Wan ;
Abdullah, Huda ;
Zulfakar, Mohd Syafiq ;
Islam, Mohammad Tariqul ;
Bais, Badariah ;
Shaari, Sahbudin .
JOURNAL OF SOL-GEL SCIENCE AND TECHNOLOGY, 2014, 71 (03) :477-489
[46]   Structure, sintering behavior, and microwave dielectric properties of (1-x) CaWO4-xYLiF4 (0.02 ≤ x ≤ 0.10) ceramics [J].
Bian, Jian Jiang ;
Ding, Yao Min .
MATERIALS RESEARCH BULLETIN, 2015, 67 :245-250
[47]   Effects of Ti4+ substitution on microstructure and microwave dielectric properties of ZnNb2(1-x)TiXO(6-3x) ceramics [J].
Zhang, YC ;
Yue, ZX ;
Wang, J ;
Gui, ZL ;
Li, LT .
HIGH-PERFORMANCE CERAMICS III, PTS 1 AND 2, 2005, 280-283 :19-22
[48]   Microwave dielectric properties of temperature stable (1-x)Li3Mg2SbO6-xBa3(VO4)2 composite ceramics [J].
Yao, Guo-guang ;
Pei, Cuijin ;
Gong, Yi ;
Ren, Zhaoyu ;
Liu, Peng .
JOURNAL OF MATERIALS SCIENCE-MATERIALS IN ELECTRONICS, 2018, 29 (12) :9979-9983
[49]   Dielectric properties of a new ceramic system (1-x)Mg4Nb2O9-xCaTiO3 at microwave frequency [J].
Huang, Cheng-Liang ;
Chen, Jhih-Yong ;
Liang, Chih-Chao .
MATERIALS RESEARCH BULLETIN, 2009, 44 (05) :1111-1115
[50]   Enhanced Sinterability and Microwave Dielectric Performance of (1 − x)ZnAl2O4-xLi4/3Ti5/3O4 Ceramics [J].
Nan Wang ;
Huanfu Zhou ;
Jianzhang Gong ;
Guangchao Fan ;
Xiuli Chen .
Journal of Electronic Materials, 2016, 45 :3157-3161