Characteristics of carbonized sludge for co-combustion in pulverized coal power plants

被引：88

作者：

Park, Sang-Woo ^{[1
]}

Jang, Cheol-Hyeon ^{[1
]}

机构：

[1] Hanbat Natl Univ, Dept Environm Engn, Taejon 305719, South Korea

来源：

WASTE MANAGEMENT | 2011年 / 31卷 / 03期

关键词：

DRIED SEWAGE-SLUDGE; BIOMASS; COMBUSTION; BOILER; FUEL;

D O I：

10.1016/j.wasman.2010.10.009

中图分类号：

X [环境科学、安全科学];

学科分类号：

08 ; 0830 ;

摘要：

Co-combustion of sewage sludge can destabilize its combustion profile due to high volatility, which results in unstable flame. We carried out fuel reforming for sewage sludge by way of carbonization at pyrolysis temperature of 300-500 degrees C. Fuel characteristics of carbonized sludge at each temperature were analyzed. As carbonization temperature increased, fuel ratio increased, volatile content reduced, and atomic ratio relation of H/C and O/C was similar to that of lignite. The analysis result of FT-IR showed the decrease of aliphatic C-H bond and O-C bond in carbonization. In the analysis result of TG-DTG, the thermogravimetry reduction temperature of carbonized sludge (CS400) was proven to be higher than that of dried sludge, but lower than that of sub-bituminous coal. Hardgrove grindability index increased in proportion to fuel ratio increase, where the carbonized sludge value of 43-110 was similar or higher than the coal value of 49-63. As for ash deposits, slagging and fouling index were higher than that of coal. When carbonized sludge (CS400) and coal were co-combusted in 1-10% according to calorific value, slagging tendency was low in all conditions, and fouling tendency was medium or high according to the compositions of coal. (C) 2010 Elsevier Ltd. All rights reserved.

引用

页码：523 / 529

页数：7

共 32 条

[11] Investigation of slagging in pulverized fuel co-combustion of biomass and coal at a pilot-scale test facility [J].

Heinzel, T ;

Siegle, V ;

Spliethoff, H ;

Hein, KRG .

FUEL PROCESSING TECHNOLOGY, 1998, 54 (1-3) :109-125

[12] On the technical and economic issues involved in the co-firing of coal and waste in a conventional pf-fired power station [J].

Ireland, SN ;

Mcgrellis, B ;

Harper, N .

FUEL, 2004, 83 (7-8) :905-915

[13] Combustion properties of biomass [J].

Jenkins, BM ;

Baxter, LL ;

Miles, TR ;

Miles, TR .

FUEL PROCESSING TECHNOLOGY, 1998, 54 (1-3) :17-46

[14]

*JSWA, 2008, REP TECHN EV SOL FUE

[15]

KEEI (2009) Korea Energy Economics Institute, 2009, YB EN STAT

[16]

*KEM, 2008, KOR MIN ENV STUD QUA

[17]

*KEM, 2008, KOR MIN ENV STAT SEW

[18]

*KERI, 2009, STUD DES APPL RPS SY

[19]

KIM MY, 2009, P KOR SOC IND ENG CH, P93

[20]

*KPE, 2009, STAT GEN FAC

← 1 2 3 4 →