Ionic liquid as adjuvant in an aqueous biphasic system composed of polyethylene glycol for green separation of Pd(II) from hydrochloric solution

被引:22
作者
Tang, Nian [1 ]
Wang, Yating [1 ]
Liu, Meng [1 ]
Liu, Lingli [1 ]
Yin, Chun [1 ]
Yang, Xiangjun [1 ]
Wang, Shixiong [1 ]
机构
[1] Yunnan Univ, Key Lab Med Chem Nat Resource, Sch Chem Sci & Technol, Minist Educ, Kunming, Yunnan, Peoples R China
基金
中国国家自然科学基金;
关键词
Palladium(II); Aqueous biphasic systems (ABS); Extraction; Ionic liquid; Adjuvant; 2-PHASE SYSTEMS; RECOVERY; EXTRACTION; PURIFICATION; PALLADIUM; PARTITION; SOLVENT; 1-ALKYL-3-METHYLIMIDAZOLIUM; EQUILIBRIA; PLATINUM;
D O I
10.1016/j.seppur.2020.116898
中图分类号
TQ [化学工业];
学科分类号
0817 ;
摘要
An aqueous biphasic system (ABS) is considered to be an environmentally friendly technology for the extraction of diverse substances because the main component of the two phases is water. In this study, extraction behaviors of palladium(II) from hydrochloric solution using a typical polymer/salt ABS with ionic liquid (IL) as an adjuvant were studied. Three imidazolium-based ionic liquids ([C(n)mim]Br, n = 4, 6 and 8) were used to tune the properties of the ABS to enhance the extraction performance of Pd(II). The parameters that influence palladium extraction including IL species, IL concentration, salinity, original Pd(II) concentration, equilibrium pH, temperature, and contact time, were systematically studied and discussed. These results demonstrate that incorporating ILs into the PEG2000/salt ABS markedly improved the extraction efficiency, and 96-99% of Pd(II) was distributed into the PEG-rich phase. Among the three imidazolium-based ILs, the maximum extraction efficiency was achieved by the IL that had the shortest alkyl chain attached to the imidazole ring, and it can be interpreted that the electrostatic attraction was the main driving force during Pd(II) extraction. The results of FT-IR and TEM characterization show that the anionic PdCl42- transferred into the PEG-rich phase via anion exchange with the anionic Br- in [C(4)mim]Br, and the mechanism was confirmed by the stoichiometry of the extracted species of [2C(4)mim( +center dot)PdCl(4)(2-)]. Hydrazine hydrate (80 wt%) completely reduced Pd(II) in the PEG-rich phase, and EDX and SEM were used to analyze the sediments. The results established that the developed polymer/salt ABS with IL as an adjuvant is a potential environmentally friendly extraction system for palladium recovery from an acidic media.
引用
收藏
页数:9
相关论文
共 50 条
[31]   On the selective separation of metal ions from hydrochloride aqueous solution by pertraction through supported ionic liquid membranes [J].
de los Rios, A. P. ;
Hernandez-Fernandez, F. J. ;
Lozano, L. J. ;
Sanchez-Segado, S. ;
Ginesta-Anzola, A. ;
Godinez, C. ;
Tomas-Alonso, F. ;
Quesada-Medina, J. .
JOURNAL OF MEMBRANE SCIENCE, 2013, 444 :469-481
[32]   Separation of Pt(IV), Pd(II), Ru(III) and Rh(III) from model chloride solutions by liquid-liquid extraction with phosphonium ionic liquids [J].
Rzelewska-Piekut, Martyna ;
Regel-Rosocka, Magdalena .
SEPARATION AND PURIFICATION TECHNOLOGY, 2019, 212 :791-801
[33]   Effect of Cu(II) and Al(III) on the Extraction and Separation of Pt(IV) and Pd(II) from Concentrated Hydrochloric Acid Solution with Alamine336 [J].
Lee, Manseung ;
Ahn, Jonggwan ;
Sun, Panpan .
KOREAN JOURNAL OF METALS AND MATERIALS, 2010, 48 (02) :148-153
[34]   Extraction and separation of thorium(IV) and uranium(VI) with 4-oxaheptanediamide into ionic liquid system from aqueous solution [J].
Ren, Peng ;
Li, Yang ;
Wang, Zhifen ;
Geng, Yanxia ;
Yu, Tao ;
Hua, Rong .
CHEMICAL PAPERS, 2020, 74 (07) :2049-2057
[35]   Purification of β-mannanase derived from Bacillus subtilis ATCC 11774 using ionic liquid as adjuvant in aqueous two-phase system [J].
Aziz, Nur Fazrin Husna Abdul ;
Abbasiliasi, Sahar ;
Ng, Hui Suan ;
Phapugrangkul, Pongsathon ;
Abu Bakar, Mohamad Hafizi ;
Tam, Yew Joon ;
Tan, Joo Shun .
JOURNAL OF CHROMATOGRAPHY B-ANALYTICAL TECHNOLOGIES IN THE BIOMEDICAL AND LIFE SCIENCES, 2017, 1055 :104-112
[36]   Efficient separation of tocopherol homologues in vegetable oil by ionic-liquid-based countercurrent chromatography using a non-aqueous biphasic system [J].
Fan, Chen ;
Li, Nai ;
Cao, Xueli .
JOURNAL OF SEPARATION SCIENCE, 2020, 43 (05) :970-977
[37]   Purification of the Recombinant Green Fluorescent Protein Using Aqueous Two-Phase System Composed of Recyclable CO2-Based Alkyl Carbamate Ionic Liquid [J].
Song, Cher Pin ;
Liew, Poh En ;
Teh, Zora ;
Lim, Schian Pei ;
Show, Pau Loke ;
Ooi, Chien Wei .
FRONTIERS IN CHEMISTRY, 2018, 6
[38]   Ionic liquid 1-butyl-3-methylimidazolium bromide as a promoter for the formation and extraction capability of poly(ethylene glycol)-potassium citrate aqueous biphasic system at T=298.15 K [J].
Hamzehzadeh, Sholeh ;
Vasiresh, Maryam .
FLUID PHASE EQUILIBRIA, 2014, 382 :80-88
[39]   Aqueous two-phase system (polyethylene glycol plus ionic liquid) for extraction of α-amylase: phase diagrams, systems characterization and partition study [J].
Gandolfi, O. R. R. ;
Goncalves, G. R. F. ;
Batista, I. C. ;
Fontan, R. C. I. ;
Veloso, C. M. ;
Bonomo, R. C. F. .
BRAZILIAN JOURNAL OF CHEMICAL ENGINEERING, 2020, 37 (03) :595-606
[40]   Facile and effective separation of polysaccharides and proteins from Cordyceps sinensis mycelia by ionic liquid aqueous two-phase system [J].
Yan, Jing-Kun ;
Ma, Hai-Le ;
Pei, Juan-Juan ;
Wang, Zhen-Bin ;
Wu, Jian-Yong .
SEPARATION AND PURIFICATION TECHNOLOGY, 2014, 135 :278-284