A Novel Sequential Approach for the Design of Heat Exchanger Networks

被引:10
|
作者
Caballero, Jose A. A. [1 ]
Pavao, Leandro V. V. [2 ]
Costa, Caliane B. B. [2 ]
Ravagnani, Mauro A. S. S. [2 ]
机构
[1] Univ Alicante, Inst Chem Proc Engn, Alicante, Spain
[2] Univ Estadual Maringa, Dept Chem Engn, Maringa, Brazil
来源
FRONTIERS IN CHEMICAL ENGINEERING | 2021年 / 3卷
关键词
superstructure; temperature intervals; optimization; MILP-MINLP; sequential approach; heat exchanger networks;
D O I
10.3389/fceng.2021.733186
中图分类号
Q81 [生物工程学(生物技术)]; Q93 [微生物学];
学科分类号
071005 ; 0836 ; 090102 ; 100705 ;
摘要
This paper presents a new algorithm for the design of heat exchanger networks (HEN) that tries to take advantage of the strengths of the sequential and simultaneous approaches. It is divided into two sequential parts. The first one is an adaptation of the transportation model (TransHEN). It maintains the concept of temperature intervals and considers the possibility of heat transfer between all the hot and cold streams inside those intervals, and at the same time it allows the a priori calculation of the logarithmic mean temperature difference between all possible heat exchanges, and therefore it maintains the area estimation linear in the model. The second step (HENDesign model), uses a superstructure that contains all the possible alternatives in which the matches predicted by the first stage model can exchange heat to design the final heat exchanger network. Unlike the sequential approach, in this model, all heat flows, temperatures, areas, etc. are reoptimized maintaining the set of matches predicted in the first stage. The model is highly nonlinear and nonconvex, however, it is relatively easy to get good results, because the model starts with the values predicted by the TransHEN model. The algorithm has been tested using fifteen benchmark problems commonly used in literature to compare the performance of heat exchanger network algorithms. In eleven out of the fifteen cases present better or equal results than the best ones reported in the open literature. In three the results presented only marginal differences in total annualized cost (lower than 0.5%) and only a difference of 2.4% in the largest one.
引用
收藏
页数:13
相关论文
共 50 条
  • [21] Active Bypass Design for Optimal Operation of Heat Exchanger Networks
    Gu, Siwen
    Liu, Linlin
    Du, Jian
    Song, Haodong
    Meng, Qingwei
    2017 6TH INTERNATIONAL SYMPOSIUM ON ADVANCED CONTROL OF INDUSTRIAL PROCESSES (ADCONIP), 2017, : 55 - 60
  • [22] A heuristic Lagrangean approach for the synthesis of multiperiod heat exchanger networks
    Escobar, Marcelo
    Trierweiler, Jorge O.
    Grossmann, Ignacio E.
    APPLIED THERMAL ENGINEERING, 2014, 63 (01) : 177 - 191
  • [23] Optimal integration of organic Rankine cycles into process heat exchanger networks: A simultaneous approach
    Watanapanich, Supaluck
    Li, Sung-Ta
    Lee, Jui-Yuan
    ENERGY CONVERSION AND MANAGEMENT, 2022, 260
  • [24] Hypertargets: a Conceptual Programming approach for the optimisation of industrial heat exchanger networks - II. Retrofit design
    Briones, V
    Kokossis, AC
    CHEMICAL ENGINEERING SCIENCE, 1999, 54 (04) : 541 - 561
  • [25] Scheduling of heat exchanger cleaning in refinery heat exchanger networks
    Smaïli, F
    Vassiliadis, VS
    Wilson, DI
    PROCEEDINGS OF AN INTERNATIONAL CONFERENCE ON MITIGATION OF HEAT EXCHANGER FOULING AND ITS ECONOMIC AND ENVIRONMENTAL IMPLICATIONS, 2001, : 292 - 300
  • [26] Optimal allocation of cleanings in heat exchanger networks
    Assis, Bruna C. G.
    Lemos, Julia C.
    Queiroz, Eduardo M.
    Pessoa, Fernando L. P.
    Liporace, Fabio S.
    Oliveira, Sergio G.
    Costa, Andre L. H.
    APPLIED THERMAL ENGINEERING, 2013, 58 (1-2) : 605 - 614
  • [27] Synthesis of heat-integrated water networks considering detailed heat exchanger design
    Ibric, Nidret
    Ahmetovic, Elvis
    Kravanja, Zdravko
    Gundersen, Truls
    APPLIED THERMAL ENGINEERING, 2024, 254
  • [28] Heat exchanger network synthesis with detailed exchanger designs-2. Hybrid optimization strategy for synthesis of heat exchanger networks
    Kazi, Saif R.
    Short, Michael
    Isafiade, Adeniyi J.
    Biegler, Lorenz T.
    AICHE JOURNAL, 2021, 67 (01)
  • [29] Inverse system based decoupling design and control strategy for crude oil heat exchanger networks
    Sun, Lin
    Wan, Chuanchang
    Zhu, Tianyu
    Luo, Xionglin
    APPLIED THERMAL ENGINEERING, 2025, 258
  • [30] Design optimization of multi-period heat exchanger networks based on continuous energy saving
    Zhu Z.
    Sun L.
    Luo X.
    Sun, Lin (sunlin@cup.edu.cn), 1600, Materials China (67): : 5176 - 5182