Synthesis, characterization and heterogeneous catalytic application of copper integrated mesoporous matrices

被引:24
|
作者
Das, Swapan K. [1 ]
Mukherjee, Sanghamitra [1 ]
Lopes, Luis M. F. [2 ,3 ]
Ilharco, Laura M. [2 ,3 ]
Ferraria, Ana M. [2 ,3 ]
Botelho do Rego, Ana M. [2 ,3 ]
Pombeiro, Armando J. L. [1 ]
机构
[1] Univ Lisbon, Ctr Quim Estrut, Inst Super Tecn, P-1049001 Lisbon, Portugal
[2] Univ Lisbon, Ctr Quim Fis Mol, P-1049001 Lisbon, Portugal
[3] Univ Lisbon, Inst Super Tecn, IN Inst Nanosci & Nanotechnol, P-1049001 Lisbon, Portugal
关键词
LIQUID-PHASE OXIDATION; SELECTIVE OXIDATION; PEROXIDATIVE OXIDATION; CYCLOHEXANE OXIDATION; EFFICIENT CATALYST; SBA-15; PERFORMANCE; SILICA; VANADIUM; OXIDE;
D O I
10.1039/c3dt52510d
中图分类号
O61 [无机化学];
学科分类号
070301 ; 081704 ;
摘要
Ordered copper integrated mesoporous silicate catalysts (CuMSC) have been synthesized by the utilization of the amphiphilic tri-block copolymer pluronic F127 as a structure directing agent (SDA) under acidic aqueous conditions. The mesophase of the materials was investigated using small-angle powder X-ray diffraction and transmission electron microscopic (TEM) image analysis. N-2 adsorption-desorption studies show that the BET surface area of CuMSC (214-407 m(2) g(-1)) is lower than that of pure silica (611 m(2) g(-1)) and has smaller average pore dimensions (4.0-5.0 nm), both prepared following the same synthetic route. The reduction of pore size and surface area points to incorporation of copper within the silicate network. FEG-SEM results suggest that the materials have a plate-like morphology and are composed of very tiny nanoparticles. EDS surface chemical analysis was utilized for the detection of the distribution of Si, O and Cu in the matrix. The FT IR spectral study suggests the complete removal of the surfactants from the calcined materials and the presence of Si-O-Cu bonds for high nominal contents. X-ray photoelectron spectroscopy (XPS) and UV-vis reflectance spectra show the oxidation state of copper and coordination mode, respectively. These mesoporous materials display a good catalytic activity in the oxidation of cyclohexane to cyclohexanone and cyclohexanol in the presence of the green oxidant hydrogen peroxide. The maximum yield (cyclohexanone and cyclohexanol) was ca. 29% and the TON (turnover number) was 276 under optimal reaction conditions. The good catalytic activity could be attributed to the large surface area and the presence of a high number of active sites located at the surface of the material, as well as to its stability. The catalysts showed negligible loss of activity after five cycles.
引用
收藏
页码:3215 / 3226
页数:12
相关论文
共 50 条
  • [41] Synthesis, characterization, and catalytic application of copper(I) nitrile cations with perfluorinated weakly coordinating anions
    Yanmei Zhang
    Wei Sun
    Ana M. Santos
    Fritz E. Kühn
    Catalysis Letters, 2005, 101 : 35 - 41
  • [42] Synthesis, characterization and catalytic application of zeolite based heterogeneous catalyst of iron(III), nickel(II) and copper(II) salen complexes for oxidation of organic pollutants
    Solomon Legese Hailu
    Balachandran Unni Nair
    Mesfin Redi-Abshiro
    Rathinam Aravindhan
    Isabel Diaz
    Merid Tessema
    Journal of Porous Materials, 2015, 22 : 1363 - 1373
  • [43] Rhenium, palladium, and copper pyridylalkoxide complexes: Synthesis, structural characterization, and catalytic application in epoxidation reactions
    Lobmaier, Gerhard M.
    Frey, Guido D.
    Dewhurst, Rian D.
    Herdtweck, Eberhardt
    Herrmann, Wolfgang A.
    ORGANOMETALLICS, 2007, 26 (25) : 6290 - 6299
  • [44] Synthesis, characterization and catalytic application of zeolite based heterogeneous catalyst of iron(III), nickel(II) and copper(II) salen complexes for oxidation of organic pollutants
    Hailu, Solomon Legese
    Nair, Balachandran Unni
    Redi-Abshiro, Mesfin
    Aravindhan, Rathinam
    Diaz, Isabel
    Tessema, Merid
    JOURNAL OF POROUS MATERIALS, 2015, 22 (05) : 1363 - 1373
  • [45] Synthesis, characterization, and catalytic application of copper(I) nitrile cations with perfluorinated weakly coordinating anions
    Zhang, YM
    Sun, W
    Santos, AM
    Kühn, FE
    CATALYSIS LETTERS, 2005, 101 (1-2) : 35 - 41
  • [46] Synthesis and size control of copper nanoparticles and their catalytic application
    Jain, Shikha
    Jain, Ankita
    Kachhawah, Pranav
    Devra, Vijay
    TRANSACTIONS OF NONFERROUS METALS SOCIETY OF CHINA, 2015, 25 (12) : 3995 - 4000
  • [47] Catalytic application of copper iodide nanoparticles in organic synthesis
    Huang, Jincheng
    Lu, Duyou
    Mandal, Tanmay
    SYNTHETIC COMMUNICATIONS, 2021, 51 (13) : 1923 - 1946
  • [48] Synthesis, Characterization, and Biofuel Application of Mesoporous Zirconium Oxophosphates
    Das, Swapan K.
    Bhunia, Manas K.
    Sinha, Anil K.
    Bhaumik, Asim
    ACS CATALYSIS, 2011, 1 (05): : 493 - 501
  • [49] Synthesis, characterization and catalytic activity of copper incorporated and immobilized mesoporous MCM-41 in the single step amination of benzene
    Parida, K. M.
    Rath, Dharitri
    Dash, S. S.
    JOURNAL OF MOLECULAR CATALYSIS A-CHEMICAL, 2010, 318 (1-2) : 85 - 93
  • [50] Synthesis, characterization and catalytic application of tin phosphate
    Patel, SM
    Chudasama, UV
    INDIAN JOURNAL OF CHEMISTRY SECTION A-INORGANIC BIO-INORGANIC PHYSICAL THEORETICAL & ANALYTICAL CHEMISTRY, 2002, 41 (09): : 1864 - 1866