Kinetics of high-temperature water-gas shift reaction over two iron-based commercial catalysts using simulated coal-derived syngases

被引:138
作者
Hla, San Shwe [1 ]
Park, D. [1 ]
Duffy, G. J. [2 ]
Edwards, J. H. [2 ]
Roberts, D. G. [1 ]
Ilyushechkin, A. [1 ]
Morpeth, L. D. [1 ]
Nguyen, T. [1 ]
机构
[1] CSIRO Energy Technol, Pullenvale, Qld 4069, Australia
[2] CSIRO Energy Technol, Newcastle, NSW 2300, Australia
关键词
Kinetics; Water-gas shift reaction; Fe-Cr oxide catalyst; Coal-derived syngas; OXIDE CATALYST; HYDROGEN; COPPER;
D O I
10.1016/j.cej.2008.09.023
中图分类号
X [环境科学、安全科学];
学科分类号
08 ; 0830 ;
摘要
The kinetics of the water-gas shift (WGS) reaction over two iron-chromium based commercial catalysts has been studied. The experiments were performed in a differential reactor at a constant temperature of 450 degrees C and a space velocity of 1.9 m(3) g(cat)(-1) h(-1) at approximately atmospheric pressure. The effects of CO. CO(2), H(2)O and H(2) concentration on WGS reaction rate were determined over both catalysts using selected gas compositions that might be encountered in coal based gasification system of the dry-feed and slurry-feed types and at the backend of conventional fixed-bed and catalytic membrane reactors. It was found that the rates of the WGS reaction (in mol g(cat)(-1)s(-1)) over two commercial catalysts (referred to as HTC1 and HTC2) at a reaction temperature of 450 degrees C can be expressed by the following power-law Fate models: For HTC1 [GRAPHICS] It was observed that HTC1 promotes (he Fate of WGS reaction when the in let gas consists of higher CO concentration, and lower CO(2) and H(2) concentration. Due to the less-negative reaction order with respect to CO(2), HTC2 was found to be more applicable to the gas streams with higher CO(2) levels, which are likely to be found on the retentate side at the backend of a catalytic membrane reactor. Crown Copyright (c) 2008 Published by Elsevier B.V. All rights reserved.
引用
收藏
页码:148 / 154
页数:7
相关论文
共 18 条
[1]   HYDROGEN-PRODUCTION FROM THE LOW-TEMPERATURE WATER-GAS SHIFT REACTION - KINETICS AND SIMULATION OF THE INDUSTRIAL REACTOR [J].
AMADEO, NE ;
LABORDE, MA .
INTERNATIONAL JOURNAL OF HYDROGEN ENERGY, 1995, 20 (12) :949-956
[2]  
[Anonymous], 2000, PEDIGCC98002 NETL
[3]   An improved microkinetic model for the water gas shift reaction on copper [J].
Callaghan, C ;
Fishtik, I ;
Datta, R ;
Carpenter, M ;
Chmielewski, M ;
Lugo, A .
SURFACE SCIENCE, 2003, 541 (1-3) :21-30
[4]   Water gas shift reaction kinetics and reactor modeling for fuel cell grade hydrogen [J].
Choi, Y ;
Stenger, HG .
JOURNAL OF POWER SOURCES, 2003, 124 (02) :432-439
[5]   DEPENDENCE OF THE KINETICS OF THE LOW-TEMPERATURE WATER GAS SHIFT REACTION ON THE CATALYST OXYGEN ACTIVITY AS INVESTIGATED BY WAVEFRONT ANALYSIS [J].
FIOLITAKIS, E ;
HOFMANN, H .
JOURNAL OF CATALYSIS, 1983, 80 (02) :328-339
[6]   KINETICS OF THE CARBON-MONOXIDE CONVERSION WITH STEAM AT ELEVATED PRESSURES [J].
FOTT, P ;
VOSOLSOBE, J ;
GLASER, V .
COLLECTION OF CZECHOSLOVAK CHEMICAL COMMUNICATIONS, 1979, 44 (03) :652-659
[7]   Stationary and transient kinetics of the high temperature water-gas shift reaction [J].
Keiski, RL ;
Salmi, T ;
Niemisto, P ;
Ainassaari, J ;
Pohjola, VJ .
APPLIED CATALYSIS A-GENERAL, 1996, 137 (02) :349-370
[8]   Kinetics of the water-gas shift reaction over a rhodium-promoted iron-chromium oxide catalyst [J].
Lei, Y ;
Cant, NW ;
Trimm, DL .
CHEMICAL ENGINEERING JOURNAL, 2005, 114 (1-3) :81-85
[9]  
LEI Y, 2005, THESIS UNSW
[10]  
*NETL, 2000, PEDIGCC98001 NETL