Catalytic ozonation for the degradation of polyvinyl alcohol in aqueous solution using catalyst based on copper and manganese

被引:39
作者
Yan, Zhengchu [1 ]
Zhu, Jianxin [1 ]
Hua, Xiuyi [1 ]
Liang, Dapeng [1 ]
Dong, Deming [1 ]
Guo, Zhiyong [1 ]
Zheng, Na [1 ]
Zhang, Liwen [1 ]
机构
[1] Jilin Univ, Coll New Energy & Environm,Minist Educ, Key Lab Groundwater Resources & Environm, Key Lab Water Resources & Aquat Environm Jilin Pr, Changchun 130012, Peoples R China
关键词
Degradation; Heterogeneous catalytic ozonation; Hydroxyl radical; Polyvinyl alcohol; Pretreatment; Water-soluble polymer; WASTE-WATER; SURFACE-PROPERTIES; OXIDE CATALYSTS; OXIDATION; OZONE; PVA; MN; CU; ALUMINA; ACID;
D O I
10.1016/j.jclepro.2020.122856
中图分类号
X [环境科学、安全科学];
学科分类号
08 ; 0830 ;
摘要
Polyvinyl alcohol (PVA) is widely used in industries and exists in corresponding effluents. As a refractory water-soluble polymer, PVA is hard to be biologically degraded and may cause membrane blockage problem in reclaiming the wastewater. Therefore, it is necessary for PVA-containing wastewater to be pretreated. In this study, the heterogeneous catalytic ozonation to degrade PVA was investigated. The composition of catalysts was screened, the catalyst preparation and the reaction conditions were optimized, and the degradation mechanism was discussed. According to the results, gamma-alumina was selected as support, copper and manganese were selected as active components, and subsequently the complex catalyst, copper-oxygen-manganese/gamma-alumina (CMA), was formed. The optimal preparation conditions of CMA were as follows: molar ratio of copper to manganese was 1:2 while loading rate was 4 wt%; copper and manganese loaded on g-alumina successively by ultrasonic impregnation at 25 degrees C for 2.5 h, then dried at 100 degrees C for 4 h, and calcined at 500 degrees C for 4 h. When the initial concentration of PVA solution was 20 mg/L, the optimal dosage of the catalyst for catalytic ozonation was 100 mg/L. The removal rate of PVA reached 97.8% in 15 min at pH = 7, and 99.3% in 10 min at pH = 10. The leaching of the metals in CMA could be neglected, and the catalyst still had a satisfactory result after five cycles of reuse. The catalytic ozonation followed the mechanism of hydroxyl radical reaction. Although only a small fraction of PVA was mineralized after reaction, the long chains of PVA molecules were broken into smaller pieces. Therefore, it is an effective pretreatment method for reclaiming PVA-containing wastewater. (C) 2020 Elsevier Ltd. All rights reserved.
引用
收藏
页数:11
相关论文
共 50 条
  • [41] Ozonation of metoprolol in aqueous solution: ozonation by-products and mechanisms of degradation
    Tay, Kheng Soo
    Abd Rahman, Noorsaadah
    Bin Abas, Mhd Radzi
    ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH, 2013, 20 (05) : 3115 - 3121
  • [42] Ozonation of metoprolol in aqueous solution: ozonation by-products and mechanisms of degradation
    Kheng Soo Tay
    Noorsaadah Abd. Rahman
    Mhd. Radzi Bin Abas
    Environmental Science and Pollution Research, 2013, 20 : 3115 - 3121
  • [43] OPTIMIZATION OF COD REMOVAL FROM POLYVINYL ALCOHOL AQUEOUS SOLUTION VIA ELECTROCOAGULATION USING RESPONSE SURFACE METHODOLOGY
    Huang, Kai-Yu
    Shu, Chi-Min
    FRESENIUS ENVIRONMENTAL BULLETIN, 2014, 23 (1A): : 207 - 214
  • [44] Ozonation of Reactive Orange 4 dye aqueous solution using mesoporous Cu/SBA-15 catalytic material
    Ghuge, Santosh P.
    Saroha, Anil K.
    JOURNAL OF WATER PROCESS ENGINEERING, 2018, 23 : 217 - 229
  • [45] Treatment of Polyvinyl Alcohol from Aqueous Solution via Electrocoagulation
    Wang, Chih-Ta
    Chou, Wei-Lung
    Huang, Kai-Yu
    SEPARATION SCIENCE AND TECHNOLOGY, 2010, 45 (02) : 212 - 220
  • [46] Heterogeneous catalytic ozonation of 2-chlorophenol aqueous solution with alumina as a catalyst
    Ni, CH
    Chen, JN
    WATER SCIENCE AND TECHNOLOGY, 2001, 43 (02) : 213 - 220
  • [47] Ultrasound-Enhanced Catalytic Ozonation Oxidation of Ammonia in Aqueous Solution
    Liu, Chen
    Chen, Yunnen
    He, Caiqing
    Yin, Ruoyu
    Liu, Jun
    Qiu, Tingsheng
    INTERNATIONAL JOURNAL OF ENVIRONMENTAL RESEARCH AND PUBLIC HEALTH, 2019, 16 (12)
  • [48] Enhanced mechanism of catalytic ozonation by ultrasound with orthogonal dual frequencies for the degradation of nitrobenzene in aqueous solution
    Zhao, Lei
    Ma, Jun
    Zhai, Xuedong
    ULTRASONICS SONOCHEMISTRY, 2010, 17 (01) : 84 - 91
  • [49] Study on the photo-Fenton degradation of polyvinyl alcohol in aqueous solution
    Giroto, J. A.
    Guardani, R.
    Teixeira, A. C. S. C.
    Nascimento, C. A. O.
    CHEMICAL ENGINEERING AND PROCESSING-PROCESS INTENSIFICATION, 2006, 45 (07) : 523 - 532
  • [50] Comparison of non-catalytic and catalytic ozonation processes of three different aqueous single dye solutions with respect to powder copper sulfide catalyst
    Pirgalioglu, Saltuk
    Ozbelge, Tuelay A.
    APPLIED CATALYSIS A-GENERAL, 2009, 363 (1-2) : 157 - 163