Evaluation of mass and energy balances in the integrated microalgae growth-anaerobic digestion process

被引:64
作者
Alcantara, Cynthia [1 ]
Garcia-Encina, Pedro A. [1 ]
Munoz, Raul [1 ]
机构
[1] Univ Valladolid, Dept Chem Engn & Environm Technol, Valladolid, Spain
关键词
Biomethanization; Mass and energy balances; Microalgae anaerobic digestion; Nutrient recovery; Photosynthetic efficiency; BIODIESEL PRODUCTION; MIXOTROPHIC CULTIVATION; CHLORELLA-VULGARIS; WASTE-WATER; PHOTOBIOREACTOR; BIOFUELS; MODEL; PLANT; OIL;
D O I
10.1016/j.cej.2013.01.100
中图分类号
X [环境科学、安全科学];
学科分类号
08 ; 0830 ;
摘要
The production of biofuels based on microalgae as feedstock is associated with a high demand of nutrients, mostly nitrogen and phosphorus. The integration of microalgae growth with anaerobic digestion can significantly improve the economic and energy balance of such a promising platform technology. However, the lack of information about the fundamental mass and energy balances of this integrated process restricts its full scale implementation. This study quantified both the mass (carbon, nitrogen and phosphorus) and energy balances in the integrated process of Chlorella sorokiniana cultivation (under photoautotrophic and mixotrophic conditions) coupled with anaerobic digestion in batch mode in order to properly design the microalgae growth-anaerobic digestion process and minimize the overall microalgae cultivation costs. Under fully photoautotrophic growth, the productivity during the microalgae exponential growth phase was 147 g/m(3) d, with an overall photosynthetic efficiency of 7.4%. The productivity of the mixotrophically-grown microalgae was 165 g/m(3) d. However, the photosynthetic activity of C sorokiniana decreased at increasing glucose concentrations in the tested range (180-440 g/m(3)). During the anaerobic digestion of photoautotrophically-grown microalgae 55 +/- 1% of the initial carbon present in the biomass was hydrolyzed (15 +/- 1% to C-CO2 and 33 +/- 1% to C-CH4). The potential recovery of the N and P present in the biomass accounted for 59 +/- 2% as N-NH4+ and 89 +/- 2% as P-PO4-3, respectively. During the anaerobic digestion of mixotrophically-grown microalgae, 46 +/- 1% of the initial carbon as biomass was hydrolyzed (14 +/- 1% to C-CO2 and 36 +/- 1% to C-CH4) with a nutrient recovery of 70 +/- 3% as N-NH4+ and 77 +/- 2% as P-PO4-3. The energy recovery from the chemical energy fixed as biomass under photoautotrophic and mixotrophic conditions was 48% and 61%, respectively, and decreased to approximate to 3.5% when referred to the total energy available during the growth stage. (C) 2013 Elsevier B.V. All rights reserved.
引用
收藏
页码:238 / 246
页数:9
相关论文
共 61 条
[1]   Mixotrophic cultivation of Chlorella vulgaris using industrial dairy waste as organic carbon source [J].
Abreu, Ana P. ;
Fernandes, Bruno ;
Vicente, Antonio A. ;
Teixeira, Jose ;
Dragone, Giuliano .
BIORESOURCE TECHNOLOGY, 2012, 118 :61-66
[2]   Production cost of a real microalgae production plant and strategies to reduce it [J].
Acien, F. G. ;
Fernandez, J. M. ;
Magan, J. J. ;
Molina, E. .
BIOTECHNOLOGY ADVANCES, 2012, 30 (06) :1344-1353
[3]   Microalgae as a sustainable energy source for biodiesel production: A review [J].
Ahmad, A. L. ;
Yasin, N. H. Mat ;
Derek, C. J. C. ;
Lim, J. K. .
RENEWABLE & SUSTAINABLE ENERGY REVIEWS, 2011, 15 (01) :584-593
[4]   Biochemical methane potential of microalgae: Influence of substrate to inoculum ratio, biomass concentration and pretreatment [J].
Alzate, M. E. ;
Munoz, R. ;
Rogalla, F. ;
Fdz-Polanco, F. ;
Perez-Elvira, S. I. .
BIORESOURCE TECHNOLOGY, 2012, 123 :488-494
[5]  
[Anonymous], 1996, TECHNICAL REPORT
[6]  
[Anonymous], 2009, BIORESOURCE TECHNOL
[7]  
Asano T., 2002, TCHOBANOGLOUS METCAL
[8]   FREE AMMONIA INHIBITION OF ALGAL PHOTOSYNTHESIS IN INTENSIVE CULTURES [J].
AZOV, Y ;
GOLDMAN, JC .
APPLIED AND ENVIRONMENTAL MICROBIOLOGY, 1982, 43 (04) :735-739
[9]   Assessing the influence of the carbon oxidation-reduction state on organic pollutant biodegradation in algal-bacterial photobioreactors [J].
Bahr, Melanie ;
Stams, Alfons J. M. ;
De la Rosa, Francisco ;
Garcia-Encina, Pedro A. ;
Munoz, Raul .
APPLIED MICROBIOLOGY AND BIOTECHNOLOGY, 2011, 90 (04) :1527-1536
[10]  
Baird R.B., 2005, Standard methods for the examination of water and wastewater