Assessment of elemental content of milled coal, combustion residues, and stack emitted materials: Possible environmental effects for a Canadian pulverized coal-fired power plant

Two monitoring studies were carried out at four-year intervals on a power plant that uses western Canadian subbituminous coal and generates approximately 800 Mw/h of electricity. The distributions of elements of environment concern (As, Hg, Ni, Pb, and Cd) and elements of environmental interest (B, Ba, Be, Cl, Co, Cr, Cu, Mn, Mo, Th, Se, V, U, and Zn) in milled coals, power plant ashes, and emitted materials from the stack were determined using neutron activation analysis (NAA), Inductively Coupled Plasma Emission Spectroscopy (ICPES), and Inductively Coupled Plasma-Mass spectroscopy (ICP-MS) for most elements, Graphite Furnace Atomic Absorption (GFAA) for Pb, and Cold Vapor Atomic Absorption (CVAA) for Hg. The concentrations of most of elements in milled coal are low as compared to world coals and other Canadian milled coals. For example, in both studies mercury is within the lower range of world coal. Bottom ashes from both studies have low concentrations of As, CA, Hg, Pb, and Zn, as well as low relative enrichment factors (RE) for the same elements, indicating that they were not enriched in the bottom ash. The ESP's remove most of the elements of environmental interest as indicated by their high RE ratios of greater than >0.7. The rates of input of elements of environmental concern (As, Cd, Hg, Pb and Ni) for this station were 23.65, 1.24, 0.54, 98.2 and 95.2 kg/day, respectively, of which only 0.20, 0.02, 0.31, 0.48 and 0.36 kg/day were emitted from the stack. Thus only a small amount of these elements found in the milled coal was emitted while most were captured in the bottom and the ESP ashes. Nickel has the highest rate of emission (0.48 kg/day) within the elements of environmental concern group. However, the Ni emitted from this station does not belong to the toxic species. The element with the lowest rate of emission is Cd (0.02 kg/day). The total emission of elements of environmental concern is 1.37 kg/day, which is low as compared their ambient concentrations in either rural or urban air. The total rate of emission of B, Ba, Be, Co, Cr, Cu, Mn, Mo, Se, Th, U, V, and Zn is 56.51 kg/day and is mostly comprised of the total emission of Ba (21.73 kg/day) and Zn (19.14 kg/day). (c) 2005 Elsevier B.V. All rights reserved.